Abstract:In this paper, the effect of the nonself-aligned process on the performance variation of a bottom-gate metal oxide semiconductor (MOS) transistor is discussed using a device simulator. The simulation results predict that the nonself-aligned bottom-gate MOS transistor cannot be scaled into the deep submicron regions. A simple fully self-aligned bottom-gate (FSABG) metal oxide semiconductor field effect transistor (MOSFET) technology is then proposed and developed. A new technique for forming thermal oxide on poly-Si serving as the bottom-gate dielectric is also investigated. It is found that the quality of the oxide on the poly-Si recrystallized by the metal induced uni-lateral crystallization.(MIUC) is much higher than that by the solid phase crystallization (SPC). Deep submicron fully self-aligned bottom-gate pMOS transistors are fabricated successfully using the proposed technology. The experimentally measured results indicate the device performances depend strongly on the channel-width, and get comparable to that of a single crystal MOSFET if the channel width is less than 0.5 mum. The effects of the channel width on the device performances are discussed. In addition, the experimental results also confirm that the proposed technology has a good control of the channel film thickness.

A Novel Self-Aligned Bottom Gate Poly-Si TFT with In-Situ LDD

A Novel Self-Aligned Double-Gate TFT Technology

Fabrication and Properties of Self-Aligned Double-Gate Poly-Si TFT

Implementation and characterization of self-aligned double-gate TFT with thin channel and thick source/drain

A Self-Aligned Double-Gate Polysilicon Tft Technology

Implementation of Fully Self-Aligned Bottom-Gate MOS Transistor

A Viable Self-aligned Bottom-Gate MOSFET Technology for High Density and Low Voltage SRAM

Deep Sub-Micron Self-Aligned Bottom-Gate Amorphous InGaZnO Thin-Film Transistors With Low-Resistance Source/Drain

Reduction of Off-Current in Self-Aligned Double-Gate TFT with Mask-Free Symmetric LDD

Self-aligned Offset Gate Poly-Si TFTs Using Photoresist Trimming Technology

A Viable Self-Aligned Bottom-Gate MOS Transistor Technology for Deep Submicron 3-D SRAM

A Bottom-Gate Metal–Oxide Thin-Film Transistor with Self-Aligned Source/Drain Regions

A Novel Ultrathin Elevated Channel Low-Temperature Poly-Si TFT

Self-Aligned Elevated-Metal Metal-Oxide Thin-Film Transistors for Displays and Flexible Electronics

Sub-100 Nm Self-Aligned Top-Gate Amorphous InGaZnO Thin-Film Transistors with Gate Insulator of 4 Nm Atomic-Layer-Deposited AlOx

A Novel Ultra-Thin Channel Poly-Si TFT Technology

Implementation of Fully Self-Aligned Homojunction Double-Gate A-Igzo Tfts

A Hybrid A-Si and Poly-Si TFTs Technology for AMOLED Pixel Circuits

Flexible Self-Aligned Double-Gate IGZO TFT

Self-Assembled Nanodielectrics for Solution-Processed Top-Gate Amorphous IGZO Thin-Film Transistors

In-Plane-Gate Oxide-Based Thin-Film Transistors Self-Aligned on Stacked Self-Assembled Monolayer/$\hbox{SiO}_{2}$ Electrolyte Dielectrics