Abstract:Abstract Monosilane (SiH 4 ) is a common precursor for the production of high-purity silicon for solar PV applications. As an alternative to carbothermic reduction of silica to produce metallurgical grade silicon with subsequent conversion to silane, an alternative route over magnesiothermic reduction of silica to Mg 2 Si has been explored in our earlier work. In the current work, silane gas production through hydrolysis of Mg 2 Si in HCl acid solution was studied. Two sources of Mg 2 Si were chosen: a commercial Mg 2 Si source and a Mg 2 Si source produced through magnesiothermic reduction of high-purity natural quartz. Effects of various parameters on the hydrolysis of Mg 2 Si, including different experimental setups, temperature of the acid solution, acid concentration, reaction time, and relative amounts of reactants were studied. The evolution of produced gases was determined by two different methods: firstly, by passing the produced gas through a KOH solution to capture Si with subsequent analysis of the Si content in the KOH solution by inductively coupled plasma mass spectrometry and secondly, on-line gas analysis by GC–MS. The silane distribution between different silane species with reaction time was evaluated and the activation energy of silane formation was calculated. The results indicated comparable silane yields obtained from the on-line GC–MS method and KOH solution analysis method, as well as for commercial Mg 2 Si and the Mg 2 Si–MgO mixture produced through magnesiothermic reduction. Furthermore, adding HCl acid to Mg 2 Si in water led to higher SiH 4 formation yield than adding Mg 2 Si to acid. However, the total silane yield for the two methods was similar at approximately 32%. Graphical Abstract

Synthesis of methylchlorosilane by direct process and its gas chromatographic analysis

Advances in synthetic technology of organosilicon monomer

Conversion of Methyltrichlorosilane in Stirred Bed Reactor by Methylalumminumchloride Method

CONVERSION AND UTILIZATION OF BYPRODUCTS IN DIRECT SYNTHESIS OF METHYLCHLOROSILANES

Study on Synthesis and Analysis of Methyltriacetoxysilane

Development of Comprehensive Utilization by Redistribution and Convertion of Methyltrichlorosilane

Synthesis of Dihydromyrcenoi-type Silane Coupling Agent

Preparation of dimethyldichlorosilane by redistributing methyltrichlorosilane and trimethylchlorosilane with AlCl3 supported catalysts

Study on Redistribution of Methyltrichlorosilane and Trimethylchlorosilane over AlCl3 Supported Catalyst

Process characteristics of Cu-based catalyst in direct synthesis of methylchlorosilanes

Synthesis of Diethoxy(methyl)vinylsilane via Hydrosilylation Reaction

Synthesis, Characterization and Application of Submicron ZrSiO4 Powder Via Sol-Gel-microemulsion-hydrothermal Method

Promoter Effects of Zn and Sn in the Direct Synthesis of Methylchlorosilanes

From silicon to silicones without dimethyldichlorosilane. Direct green mechanochemical synthesis of methylmethoxysilanes from silicon and dimethyl ether.

[Determination of chlorosilanes by gas chromatography]

Study of the Effect of Zn, Sn, and Pb Additives on the Direct Mechanochemical Synthesis of Tetramethoxysilane in the Presence of CuCl and CuO Catalysts

Effect of Copper Content on the Direct Process of Organosilane Synthesis from Silicon and Methyl Chloride

The Direct Synthesis of Methylchlorosilanes in A Fixed-Bed Reactor

A Bi-component Cu Catalyst for the Direct Synthesis of Methylchlorosilane from Silicon and Methyl Chloride

Preparation of Methyltrimethoxysilane Derived Silica Aerogel Films via Ambient Pressure Drying

Silane Gas Production Through Hydrolysis of Magnesium Silicide by Hydrochloric Acid