Abstract:Mass transfer performance is markedly improved in microchannels compared with traditional gas-liquid chemical devices. The residence time is a crucial parameter for determining the mass transfer performance. However, investigation of the residence time in gas-liquid absorption systems remains insufficient, especially in viscous gas-liquid systems with obvious flow non-uniformity between the two phases. Herein, the microscale gas-liquid flow and mass transfer performance in viscous liquids (9.0-55.4 mPa center dot s) based on the true residence time are investigated. Owing to the broad operating conditions of the gas-liquid flow ratio (0.2-6.7), both Taylor flow and bubbly flow patterns were observed. The results show that the bubble velocity gradually decreases to the minimum value with increasing flow distance in the Taylor flow pattern owing to gas absorption. Subsequently, bubble velocity gradually increases under the bubbly flow pattern, and the dominant factor of bubble velocity is pointed out. The true bubble residence time initially increases and then gradually decreases compared to the superficial time as the gas holdup decreases, based on the superficial velocity using the initial flow rates. The transition point occurs at a gas holdup of 0.2. In addition, the turning point of the different rules of the pressure drop occurs at a gas holdup of 0.5. Finally, a new dimensionless equation was proposed to predict the mass transfer coefficient and reveal the equation differences between low-and high-viscosity liquids. This work enriches the understanding of microflow characteristics and mass transfer performance in viscous solutions and provides a reliable guide for microreactor design.

Study on Hydrodynamics and Mass Transfer Characteristic of a New Gas-liquid Reactor

Experimental and Numerical Simulation on Sequential Three Phase Jet-Loop Reactor

Gas Holdup and Liquid Velocity Distributions in the Up Flow Jet-Loop Reactor

Hydrodynamics in a Novel Gas-Liquid Cocurrent Bubble Reactor and its CFD Simulation

Gas Holdup and Liquid Velocity Distribution in a Jet Loop Reactor

Measuration of Gas-Liquid Interfacial Area in Rotating Drum Reactor by Chemical Method

Gas-Liquid Mass Transfer Characteristics in a Rotating-Drum Bioreactor

Hydrodynamic and Mass Transfer of Gas-Liquid-Solid Three-Phase Internal Loop Airlift Reactors with Nanometer Solid Particles

The study on mass transfer characteristics of the intensified gas-liquid jet stirred reactor

Investigation of hydrodynamics and mass transfer in an internal loop airlift slurry reactor integrating mixing and separation

Study on Characterization of Bubble Size in a Down-flow Liquid Jet Gas Pump

Visual study on the characteristics of liquid and droplet in a novel rotor-stator reactor

Hydrodynamics and Mass Transfer Performance of Gas–liquid Microflow in Viscous Liquids

Hydrodynamic Character of Internal-Loop Airlift Reactor

Study on gas–liquid phase mass transfer coefficient of entrained flow reactor

A study on mass transfer and kinetic properties of self-mixing disk turbine stirred reactor

Characterization on Hydrodynamic Behavior in Liquid‐containing Gas‐solid Fluidized Bed Reactor

Nature and Characteristics of Gas–liquid Flow Regimes in a Micro‐packed Bed Reactor

HYDRODYNAMICS AND MASS TRANSFER OF TRIPLET LOOP BIOLOGICAL FLUIDIZED BED

Hydrodynamics and mass transfer coefficient in three-phase air-lift reactors containing activated sludge

STUDY ON THE HYDRODYNAMICS AND TRANSFER PROPERTIES OF INDUSTRIAL AIRLIFT REACTORS