Abstract:A gas-liquid exlemal-loop airlift reactor with a riser 0.47 m in diameter and 2.5 m in height and Iwo externalloop down-comers 0.08 m in diameter and 2.5 m in height were used to investigate the gas-liquid two-phase flow structure. Local phase holdups were measured simultaneously by a microconductivity probe with air as the gas phase and water as the liquid phase over a wide range of operation conditions. Liquid flow velocity measurements were performed using the electrolyte tracer measurement (ETM) technique. The hydrodynamics near the sparger zone, riser disengagement zone (zone 1), junction zone (zone 2), and down-comer disengagement zone (zone 3) were systematically examined using the CFDs at the local scale and at the riser scale, respectively. The simulation results showed that zones 1, 2, and 3 exhibit three different flow regimes, which were the secondary mixed flow regime, the mixed flow regime, and the homogeneous bubble regime, respectively. It was also indicated that turbulent kinetic energy and turbulent kinetic energy dissipation rate were influenced by a gas sparger. These results were necessary to explain these different regimes using computational fluid dynamics (CFD) to provide deeper insight at the local scale for reactor geometry, such as gas sparger, junction and disengagement zones as well as the gas-liquid phase flow microstructure. The simulation results at the local scale were difficult to obtain by experiment. The numerical simulating results of local gas holdup and local gas and liquid velocities agreed well with the experimental data at a low gas flow rate. However, large errors occurred in the simulations at a high gas flow rate, because of poor estimation of the influence of bubble-induced turbulence or the higher density of the tracer and the poor mesh refinement. The flow structure and turbulence parameters of the phases presented here were useful for designing gasliquid external-loop airlift reactors.

Experimental Investigation on Multiscale Hydrodynamics in a Novel Gas–liquid–solid Three Phase Jet‐loop Reactor

Gas Holdup and Liquid Velocity Distributions in the Up Flow Jet-Loop Reactor

CFD Simulation for Up Flow Jet-Loop Reactors by Use of Bi-Dispersed Bubble Model

Experimental and Numerical Simulation on Sequential Three Phase Jet-Loop Reactor

Gas Holdup and Liquid Velocity Distribution in a Jet Loop Reactor

Hydrodynamics in a Novel Gas-Liquid Cocurrent Bubble Reactor and its CFD Simulation

Hydrodynamics in a jet bubbling reactor: Experimental research and mathematical modeling

Experimental and Numerical Investigations of Scale-Up Effects on the Hydrodynamics of Slurry Bubble Columns

Evolution and Interaction Characteristics of Liquid Flow and Bubbles in a Jet Bubbling Column

Gas–Liquid Flow Characteristics and Performance Optimization of Industrial Downflow Jet Loop Reactor Based on Computational Fluid Dynamics

Local hydrodynamics modeling of a gas-liquid-solid three-phase airlift loop reactor

Study of Downflow Liquid Jet Loop Reactor

Spray Trajectory and 3D Droplets Distribution of Liquid Jet in Crossflow with Digital Inline Holography

Experimental Investigation on Submerged Gas-Liquid Mixture Injection into Water Through A Micro-Channel

Experimental and Numerical Simulation for Gas−Liquid Phases Flow Structure in an External-Loop Airlift Reactor

Hydrodynamic and Mass Transfer of Gas-Liquid-Solid Three-Phase Internal Loop Airlift Reactors with Nanometer Solid Particles

Hydrodynamics and Bubble Behaviour in a Three-Phase Two-Stage Internal Loop Airlift Reactor

Hydrodynamics and Local Turbulent Mixing of Submerged, Parallel Liquid Jets: Experiments and CFD Simulations

Experimental and Numerical Simulation for Liquid Phase Local Hydrodynamics in an External Loop Airlift Reactor

Experimental Study on the Local Hydrodynamic Behavior of a Three-Phase External-Loop Airlift Reactor

Jet Associated Multi-Stage Air-Lift Loop Reactor:Hydrodynamics and Mass Transfer