Abstract:The effects of different spargers on the hydrodynamics and mass transfer of an airlift loop reactor were investigated. The gas holdup, liquid loop velocity, and volumetric mass transfer coefficient of the reactor were tested using a ring orifice distributor and a jet nozzle. The study was conducted in a 6 m high airlift loop reactor at a superficial gas velocity of 0.01~0.04 m/s, and the superficial liquid velocity was maintained at 0.0154 m/s. The results showed that using the jet nozzle provided a higher gas holdup, liquid loop velocity, and mass transfer. When the superficial gas velocity was less than 0.0325 m/s, the liquid loop velocity generated by the jet nozzle was approximately 1.1-fold higher than that generated by the ring orifice distributor, and the disparity in gas holdup between the riser and downcomer enhanced the power of liquid circulation. When the superficial gas velocity was more than 0.0325 m/s, the jet kinetic power dominated the improvement in the liquid loop velocity, and the energy input from the nozzle to the airlift loop reactor was greater than 10.8 J/(s·m2). This indicated a threshold of energy input for overcoming the friction loss. In this situation, the liquid loop velocity in the jet form increased considerably, thus favoring the mixing performance and temperature uniformity of the reactor. It was also of significance for avoiding the formation of a flow dead zone in scale-up airlift loop reactors.

STUDY ON THE HYDRODYNAMICS AND TRANSFER PROPERTIES OF INDUSTRIAL AIRLIFT REACTORS

Experimental Investigation of Flow Development in Large-Scale Bubble Columns in the Churn-Turbulent Regime

Gas Holdup and Liquid Velocity Distribution in a Jet Loop Reactor

Hydrodynamic Character of Internal-Loop Airlift Reactor

Study on Hydrodynamics and Mass Transfer Characteristic of a New Gas-liquid Reactor

Hydrodynamic Behavior in Three-Phase External Loop Airlift Reactors

Investigation of hydrodynamics and mass transfer in an internal loop airlift slurry reactor integrating mixing and separation

STUDY ON THE HYDRODYNAMICS CHARACTERISTICS OF EXTERNAL-LOOP AIRLIFT SLURRY REACTORS

Hydrodynamics and Bubble Behaviour in a Three-Phase Two-Stage Internal Loop Airlift Reactor

Hydrodynamic and Mass Transfer of Gas-Liquid-Solid Three-Phase Internal Loop Airlift Reactors with Nanometer Solid Particles

Hydrodynamics of Three-Phase Internal-Loop Airlift Reactor with Large Particles

Hydrodynamics and mass transfer coefficient in three-phase air-lift reactors containing activated sludge

Multiphase flow characteristics of a novel internal-loop airlift reactor

Gas Holdup and Liquid Circulation Velocity in Gas-Liquid Two Stage Internal Loop Airlift Reactor

Influence of Sparger Type on Mass Transfer in a Pilot-Scale Internal Loop Airlift Reactor

Experimental Study on the Local Hydrodynamic Behavior of a Three-Phase External-Loop Airlift Reactor

Simulation And Experimentation On The Gas Holdup Characteristics Of A Novel Oscillating Airlift Loop Reactor

Flow behavior in the three-phase internal-loop airlift reactor with large gas recirculation through the downcomer

Flow Behavior and Mass Transfer in Three-Phase External-Loop Airlift Reactors with Large Particles

Hydrodynamics and Mass Transfer in an Airlift Loop Reactor: Comparison between Using Two Kinds of Spargers

Axial and Radial Profiles of Hydrodynamic Parameters of External-Loop Airlift Reactor