Abstract:Experiments and simulations were conducted for bubble columns with diameter of 0.2m (180mm i.d.), 0.5m (476mm i.d.) and 0.8m (760mm i.d.) at high superficial gas velocities (0.12–0.62m·s−1) and high solid concentrations (0–30vol%). Radial profiles of time-averaged gas holdup, axial liquid velocity, and turbulent kinetic energy were measured by using in-house developed conductivity probes and Pavlov tubes. Effects of column diameter, superficial gas velocity, and solid concentration were investigated in a wide range of operating conditions. Experimental results indicated that the average gas holdup remarkably increases with superficial gas velocity, and the radial profiles of investigated flow properties become steeper at high superficial gas velocities. The axial liquid velocities significantly increase with the growth of the column size, whereas the gas holdup was slightly affected. The presence of solid in bubble columns would inhibit the breakage of bubbles, which results in an increase in bubble rise velocity and a decrease in gas holdup, but time-averaged axial liquid velocities remain almost the same as that of the hollow column. Furthermore, a 2-D axisymmetric k–ε model was used to simulate heterogeneous bubbly flow using commercial code FLUENT 6.2. The lateral lift force and the turbulent diffusion force were introduced for the determination of gas holdup profiles and the effects of solid concentration were considered as the variation of average bubble diameter in the model. Results predicted by the CFD simulation showed good agreement with experimental data.

Axial and Radial Profiles of Hydrodynamic Parameters of External-Loop Airlift Reactor

Gas Holdup and Liquid Velocity Distribution in a Jet Loop Reactor

Experimental and Numerical Simulation on Sequential Three Phase Jet-Loop Reactor

CFD Simulation for Up Flow Jet-Loop Reactors by Use of Bi-Dispersed Bubble Model

Study on bubble size distribution and local gas holdup in bubble column

Gas Holdup and Liquid Velocity Distributions in the Up Flow Jet-Loop Reactor

Experimental and Numerical Investigations of Scale-Up Effects on the Hydrodynamics of Slurry Bubble Columns

Experimental Investigation on Multiscale Hydrodynamics in a Novel Gas–liquid–solid Three Phase Jet‐loop Reactor

Experimental Study on the Local Hydrodynamic Behavior of a Three-Phase External-Loop Airlift Reactor

Hydrodynamic Behavior in Three-Phase External Loop Airlift Reactors

Hydrodynamics in a jet bubbling reactor: Experimental research and mathematical modeling

Hydrodynamic Character of Internal-Loop Airlift Reactor

Influence of the Gas Distributor on the Local Hydrodynamic Behavior of an External Loop Airlift Reactor

Effect of internal on the hydrodynamics in external-loop airlift reactors

Hydrodynamics and Bubble Behaviour in a Three-Phase Two-Stage Internal Loop Airlift Reactor

Effect of Liquid Viscosity on Hydrodynamics and Bubble Behaviour of an External‐loop Airlift Reactor

Hydrodynamic and Mass Transfer of Gas-Liquid-Solid Three-Phase Internal Loop Airlift Reactors with Nanometer Solid Particles

Gas Holdup and Liquid Circulation Velocity in Gas-Liquid Two Stage Internal Loop Airlift Reactor

Experimental Study on the Bubble Behavior in Gas-Liquid External Loop Reactors

Gas Holdup, Bubble Behavior and Mass Transfer in A 5 M High Internal-Loop Airlift Reactor with Non-Newtonian Fluid

Experimental Study and Cfd Simulation of Hydrodynamic Behaviours in an External Loop Airlift Slurry Reactor