Abstract:Experiments and simulations were conducted for bubble columns with diameter of 0.2m (180mm i.d.), 0.5m (476mm i.d.) and 0.8m (760mm i.d.) at high superficial gas velocities (0.12–0.62m·s−1) and high solid concentrations (0–30vol%). Radial profiles of time-averaged gas holdup, axial liquid velocity, and turbulent kinetic energy were measured by using in-house developed conductivity probes and Pavlov tubes. Effects of column diameter, superficial gas velocity, and solid concentration were investigated in a wide range of operating conditions. Experimental results indicated that the average gas holdup remarkably increases with superficial gas velocity, and the radial profiles of investigated flow properties become steeper at high superficial gas velocities. The axial liquid velocities significantly increase with the growth of the column size, whereas the gas holdup was slightly affected. The presence of solid in bubble columns would inhibit the breakage of bubbles, which results in an increase in bubble rise velocity and a decrease in gas holdup, but time-averaged axial liquid velocities remain almost the same as that of the hollow column. Furthermore, a 2-D axisymmetric k–ε model was used to simulate heterogeneous bubbly flow using commercial code FLUENT 6.2. The lateral lift force and the turbulent diffusion force were introduced for the determination of gas holdup profiles and the effects of solid concentration were considered as the variation of average bubble diameter in the model. Results predicted by the CFD simulation showed good agreement with experimental data.

Experimental Study on the Bubble Behavior in Gas-Liquid External Loop Reactors

Study on bubble size distribution and local gas holdup in bubble column

Gas Holdup and Liquid Velocity Distribution in a Jet Loop Reactor

Experimental and Numerical Simulation on Sequential Three Phase Jet-Loop Reactor

Experimental Investigation of Flow Development in Large-Scale Bubble Columns in the Churn-Turbulent Regime

Impact of gas distributor configuration on hydrodynamics in bubble column with pipe internals

Gas Holdup and Liquid Velocity Distributions in the Up Flow Jet-Loop Reactor

Studies on hydrodynamics of slurry turbulent bubble column(Ⅰ) Gas holdup and its radial distribution

CFD Simulation for Up Flow Jet-Loop Reactors by Use of Bi-Dispersed Bubble Model

Experimental and Numerical Investigations of Scale-Up Effects on the Hydrodynamics of Slurry Bubble Columns

Experimental Investigation on Multiscale Hydrodynamics in a Novel Gas–liquid–solid Three Phase Jet‐loop Reactor

Experimental Measurement and Theoretical Analysis on Bubble Dynamic Behaviors in a Gas-Liquid Bubble Column

The Measurement of Local Gas Holdup under High Superficial Velocity in Bubble Column

Hydrodynamics in a jet bubbling reactor: Experimental research and mathematical modeling

CFD Simulation of Gas-Liquid Flow in Bubble Column

CFD simulation of effects of the configuration of gas distributors on gas–liquid flow and mixing in a bubble column

Numerical Simulations Of Fluid Dynamics And Mixing In A Large Shallow Bubble Column: Effects Of The Sparging Pipe Allocations For Multiple-Pipe Gas Distributors

Axial and Radial Profiles of Hydrodynamic Parameters of External-Loop Airlift Reactor

Influence of the Gas Distributor on the Local Hydrodynamic Behavior of an External Loop Airlift Reactor

Experimental research of the bubble distribution in a jet bubbling reactor

Experimental Study on the Local Hydrodynamic Behavior of a Three-Phase External-Loop Airlift Reactor