Abstract:The interturn short circuit fault is one of the common faults in power transformers. At present, research on interturn short circuit faults focuses on high, medium, and low voltage windings, while there is relatively little research on interturn short circuit in regulating windings. Specifically, there is a lack of reported studies on the transient electromagnetic processes, magnetic field distribution, and electromagnetic force characteristics of interturn short circuits in regulating windings unconnected to the circuit. This study presents an actual fault scenario involving interturn short circuits occurring in the untapped portion of the regulating windings of a specific power transformer. A field-circuit coupled model was established to analyze the transient electromagnetic processes during the fault, and the model's effectiveness was validated by comparing its results with actual fault recording data. Additionally, the magnetic field distribution and electromagnetic force characteristics during the fault were analyzed, and discussions were carried out regarding various ratios of short-circuit turns in the regulating windings. The results indicate that even when an interturn short circuit occurs in the portion of the regulating winding that is not connected to the circuit, the current in the short-circuited turns can reach several tens of times the rated value. Additionally, the leakage magnetic field and the electromagnetic force experienced by the short-circuited ring also increase significantly. The short-circuit ratio has a significant impact on the current of the short-circuited ring, leakage magnetic field intensity, and electromagnetic force. This study contributes to a better understanding of the impact of interturn short-circuit faults in the untapped portion of the regulating windings, offering crucial technical support for fault diagnosis and prevention of power transformers.

Analysis and Technical Improvements on Close-in Short Circuit Fault of Transformer

The Numerical Simulation Method of Transformer Internal Short-Circuit Fault

Research of the Coupling Transformer in the New Bridge-Type Solid State Fault Current Limiter System

Research on Short-Circuit Vibration of Power Transformer

Simulation Analysis of Transformer Short Circuit Fault

Analysis of interturn short circuit in regulating winding of power transformer based on field-circuit coupling

Comparative analysis of the characteristics of outlet short circuit and winding insulation fault of distribution transformer and its preventive measures

Analysis of short-circuit model for DC traction supply system

Short Circuit Current Limiter in As Network

Calculation and Analysis of Short Circuit Strength of Three-Winding Transformer

Steady-state Analysis of Internal Short Circuits of Multi-winding Power Transformer Part Ⅰ Modeling and Simulations

Fault Analysis and Treatment of Partial Discharge in 500 kV Transformer

Effects of Internal Short Circuit Faults on Short Circuit Reactance of Power Transformer

Analysis of Affecting Factors on Fault Shunt Coefficient in Substation

Modeling and Simulation of Transformer Inter-Turn Short-Circuit Faults Based on Field-Circuit Coupling

Causes of transformer failures and diagnostic methods – A review

Analysis of Fine Fault Electrothermal Characteristics of Converter Transformer Reduced-Scale Model

Analysis of Electromagnetic Transients of Three-phase Transformer's Non-synchronous Closing and Its Influence on Protection

Electromagnetic Interference in Control Cables of Substation Caused by Short Circuit Fault

Review of Detection Methods for Typical Faults in Transformer Bushings*

Fault Analysis And Simulation Of Ground-Fault Accident On Transformer In 500 Kv Ac/Dc Grids