Abstract:Abstract Recently, flat panel display technologies are based on amorphous silicon (a-Si), polycrystalline silicon (poly-Si) or amorphous oxide semiconductor (AOS) thin film transistors (TFTs) technology. In order to reach higher performance for ultra-high resolution display applications, the material selection for the channel layer is vital. AOS TFTs drawn lots of attention because of its advantages such as low leakage current, high driving current and high uniformity [1,3]. In this work, we presented a novel amorphous oxide semiconductor (AOS) material of gallium-free a-InWZnO thin film transistors (IWZO TFTs) which is very promising to be applied for ultra-high resolution display technology. Experiment In this work, we demonstrated the structure of a-IWZO TFTs processes. Figure 1 shows the schematic of the TFT cross-section. After growing a 550 nm thermal oxide layer as buffer layer, a 25-nm-thick of molybdenum was deposited by DC-sputter as the bottom gate electrode. A 10-nm-HfO 2 was deposited by plasma-enhanced atomic layer deposition (PEALD) system as high-κ gate dielectric (GI). Then, post deposition annealing (PDA) was carried out to enhance the quality of the insulator layer. Next, an ultra-thin body a-IWZO was deposited by RF-sputter as channel layer. Finally, source and drain were defined by lift-off process and the gate contact via was etched by dry etching to finish the device fabrication. Result and Discussion Figure 1(b) shows the negative gate bias stress (NGBS) transfer curve (I D -V G ) of a-IWZO TFTs with passivation layer. The experimental results have shown that passivation layer could keep the back channel of IWZO channel from exposing to oxygen and hydrogen from the atmosphere. Without the passivation layer, the back channel would contact moisture leading the diffused hydrogen atoms to fill oxygen vacancy sites and de-trap free carriers, causing the V TH shifts negatively. The ultra-thin a-IWZO TFTs with passivation layer exhibited a low subthreshold swing (S.S.) of 89.7 mV/dec, high on/off current ratio (I ON /I OFF ) of 2.1×10 7 and small threshold voltage shift (ΔV th ) of -0.097 V during NGBS of -2MV/cm with 2000s. To sum up, the passivation layer could enhance the a-IWZO TFTs reliability. Reference [1] Kamiya, H. Hosono, NPG Asia Mater ., vol. 2, pp. 15, 2010. [2] Nomura, H. Ohta, A. Takagi, T. Kamiya, M. Hirano, and H. Hosono, nature, vol. 432, no. 7016, pp. 488-492, 2004. [3] Y. Kuo, C. M. Chang, I. H. Liu, and P. T. Liu, Scientific reports, vol. 9, no. 1, pp. 1-7, 2019. Figure 1

Homogeneous double-layer amorphous Si-doped indium oxide thin-film transistors for control of turn-on voltage

Si-incorporated amorphous indium oxide thin-film transistors

High mobility of IGO/IGZO double-channel thin-film transistors by atomic layer deposition

High Performance (vth ~ 0 V, SS ~ 69 Mv/dec, IOn/IOff ~ 1010) Thin-Film Transistors Using Ultrathin Indium Oxide Channel and SiO2 Passivation

Enhancing the Stability and Mobility of TFTs via Indium-Tungsten Oxide and Zinc Oxide Engineered Heterojunction Channels Annealed in Oxygen Ambient

Realization of Tunable-Performance in Atomic Layer Deposited Hf-doped In2O3 Thin Film Transistor Via Oxygen Vacancy Modulation.

High-Performance Dual-Layer Channel Indium Gallium Zinc Oxide Thin-Film Transistors Fabricated In Different Oxygen Contents At Low Temperature

High-density carrier-accumulated and electrically stable oxide thin-film transistors from ion-gel gate dielectric

Improved Environmental Stability of InSnO Thin-Film Transistor by Interface Engineering

Mobility and Stability Enhancement of Amorphous In-Ga-Zn-O TFTs with Atomic Layer Deposited Al2O3/SiO2Stacked Insulators

Improved Performance and Bias Stability of Al2O3/IZO Thin-Film Transistors with Vertical Diffusion

In–Si–O thin-film transistors with atomic layer deposition-grown Al2O3 gate insulator

Improvement of Mobility and Stability in Oxide Thin-Film Transistors Using Triple-Stacked Structure

P‐1.1: Co‐sputtering‐deposited Hf‐doped ITO Thin Films for Thin Film Transistors Application

High Reliability Tungsten-Doped Indium Zinc Oxide Thin Film Transistors for Display Applications

Tri‐Layer Heterostructure Channel of a‐IGZO/a‐ITZO/a‐IGZO Toward Enhancement of Transport and Reliability in Amorphous Oxide Semiconductor Thin Film Transistors

35‐4: High‐Mobility and High‐Negative Bias Illumination Stress Stability Based on ITZO/IGZO Bilayer Thin Film Transistors

High Mobility Thin-Film Transistor with Solution-Processed Hafnium-Oxide Dielectric and Zinc-Indium-Tin-Oxide Semiconductor

Effect of HfO2-Based Multi-Dielectrics on Electrical Properties of Amorphous In-Ga-Zn-O Thin Film Transistors

Amorphous indium zinc oxide thin film transistors with poly-4-vinylphenol gate dielectric layers

Fluorinated Metal-Oxide Thin-Film Transistors for Circuit Implementation on a Flexible Substrate