Abstract:The growth kinetics of colloidal Al(III)-containing particles (diameter<1000 nm), nucleated in optically clear, supersaturated sodium aluminate solutions as a precursor to Al(OH)3 crystals, has been studied using dynamic light scattering. Two series of solutions were examined at 22 °C to determine the influence of Al(III) supersaturation and NaOH concentration on the initial particle growth behavior. One solution series consisted of solutions with constant Al(III) absolute supersaturation (ΔC) of 1.48 M and [NaOH] range 1.83–4.00 M ([NaOH]/[Al(III)]=1.13–2.15) and Al(III) relative supersaturation (σ)=3.86–10.36. The other solution series had a constant σ of 7.55 and [NaOH] range of 1.50–4.27 M ([NaOH]/[Al(III)]=1.18–1.54) and ΔC=0.86–3.19. The correlation between the initial particle growth rates and supersaturation (ΔC or σ) revealed marked anomalies over the entire supersaturation range studied. The growth rate remained substantially constant in the ΔC range 0.86–2.55 M (for the constant σ solution series), before increasing sharply upon a further increase of ΔC beyond 2.55 M. The variation of the growth rate with σ in the range 3.86–9.00 (for the constant ΔC solution series) was remarkably weak, contrary to expectation. At higher σ (>9.00), however, a marked increase in growth rate with increasing σ was displayed. At constant ΔC or σ, the growth rate showed a strong variation with NaOH concentration, indicating that Na+ and OH− species play a pivotal role in the Al(OH) precursor particles (nuclei) growth process. Furthermore, the kinetics of growth displayed by these nanosized particles are an order of magnitude slower than those observed for macroscopic gibbsite (γ-Al(OH)3) crystals at similar supersaturations and temperature. The difference may be rationalized in terms of particle size and Al(OH)3 dimorphic phase dependent solubility effects. An empirically adequate growth kinetics modeling was achieved when the growth rates were correlated with the Al(III) supersaturation (ΔC or σ) and the excess (free) NaOH concentration, rather than the former alone, as is commonly the case. A critical [NaOH]/[Al(III)] molar ratio of 1.27–1.35, below which the particle growth rate increased markedly and above which the rate was significantly reduced, was observed. This behavior is believed to be linked to solution speciation change that occurs at certain Al(III) and NaOH compositions.

In Situ 27Al NMR Spectroscopy of Aluminate in Sodium Hydroxide Solutions above and below Saturation with Respect to Gibbsite.

Transitions in Al Coordination during Gibbsite Crystallization Using High-Field 27Al and 23Na MAS NMR Spectroscopy

Solid-State Recrystallization Pathways of Sodium Aluminate Hydroxy Hydrates.

Ion-ion interactions enhance aluminum solubility in alkaline suspensions of nano-gibbsite (α-Al(OH)3) with sodium nitrite/nitrate

27Al Pulsed Field Gradient, Diffusion-NMR Spectroscopy of Solvation Dynamics and Ion Pairing in Alkaline Aluminate Solutions.

Crystallization and Phase Transformations of Aluminum (oxy)hydroxide Polymorphs in Caustic Aqueous Solution.

Early Stages of Alumina Sol‐Gel Formation in Acidic Media: An 27Al Nuclear Magnetic Resonance Spectroscopy Investigation

The influence of Al(III) supersaturation and NaOH concentration on the rate of crystallization of Al(OH)3 precursor particles from sodium aluminate solutions.

Synthesis of Nano-Alumina Hydroxide Sol Using Sol-gel Method

Resolving intermediates during the growth of aluminum deuteroxide (Hydroxide) polymorphs in high chemical potential solutions

Transformation of Gibbsite to Boehmite in Caustic Aqueous Solution at Hydrothermal Conditions

In Situ High Temperature High Pressure Mas Nmr Study On The Crystallization Of Alpo4-5

The crystallization mechanism of Al(OH)3 from sodium aluminate solutions

Inference of principal species in caustic aluminate solutions through solid-state spectroscopic characterization

Secondary Nucleation and Growth Kinetics of Aluminum Hydroxide Crystallization from Potassium Aluminate Solution

Small-Angle Neutron Scattering and 27Al Nmr Studies on the Microstructure and Composition of Alumina Sol-Gels

Transformation of Monomer Aluminate Ions from Tetrahedron to Octaheron

Investigation of the Homogeneous Nucleation of Al(Oh)(3) Crystals from Supersaturated Sodium Aluminate Solution by Conductance Probe

Aging processes of alumina sol-gels: characterization of new aluminum polyoxycations by aluminum-27 NMR spectroscopy

Morphology of Alumina in NaF-AlF3 Systems Determined by Raman Spectroscopy and Quantum Mechanical Calculations

Solvent Effect of Species in Sodium Aluminate Solution