Abstract:A series of gamma-Al2O3 samples modified with borate, phosphate, and sulfate were prepared by the impregnation technique and physically mixed with a methanol synthesis component (CuO-ZnO-Al2O3) at a mass ratio of 1 :2 to form hybrid catalysts. The direct synthesis of dimethyl ether (DME) from syngas was carried out over the prepared hybrid catalysts under pressurized fixed-bed continuous flow conditions. The results indicated that the modification of gamma-Al2O3 with SO42- could significantly enhance the activity for methanol dehydration and hence remarkably increase the selectivity for DME and the conversion of CO. The effects SO42- content, calcination temperature, and type of SO42- precursor on the performance of the SO42-/gamma-Al2O3 hybrid catalyst were further investigated. The results revealed that the selectivity for methanol decreased when the content 4 increased from 5% to 10%, resulting in the increase in both the selectivity for DME and the conversion of CO. However, when the SO42- content was further increased to 15 %, although the activity for methanol dehydration was increased continuously, the selectivity for DME decreased slightly due to the increased formation of byproducts hydrocarbons and CO2. Moreover, when the calcination temperature of SO42-/gamma-Al2O3 increased from 350 to 550 degrees C, both the CO conversion and the DME selectivity increased gradually, resulting from the decreased formation Of CO2. Nevertheless, a further increase in calcination temperature of SO42-/gamma-Al2O3 to 750 degrees C resulted in a significant decline in both DME selectivity and CO conversion because of the decreased activity for methanol dehydration. On the other hand, the type of SO42- precursors exerted no noticeable influence on the performance of the prepared hybrid catalysts.

Synthesis of γ-Al2O3–CeO2 catalyst with high surface area, high stability, and less coke formation for methanol dehydration reaction process

Study on Catalytic Performance and Kinetics of High Efficiency CeO2 Catalyst Prepared by Freeze Drying for the Synthesis of Dimethyl Carbonate from CO2 and Methanol

Synthesis of highly porous nanocrystalline alumina as a robust catalyst for dehydration of methanol to dimethyl ether

Hierarchical Catalysts Based on Cerium(IV) Oxide for Direct Synthesis of Dimethyl Carbonate

The Direct Synthesis of Dimethyl Ether from Syngas over Hybrid Catalysts with Sulfate-Modified Γ-Alumina As Methanol Dehydration Components

Promoted catalytic performance of sugarcane bagasse ash supported by γ‐alumina as efficient, stable, and ecofriendly catalyst for dehydration of methanol to dimethyl ether

Synthesis of Ce-doped mesoporous γ-alumina with enhanced catalytic performance for propane dehydrogenation

Facile Route for Synthesizing Ordered Mesoporous Ni–Ce–Al Oxide Materials and Their Catalytic Performance for Methane Dry Reforming to Hydrogen and Syngas

Mildly Acidic Aluminosilicate Catalysts for Stable Performance in Ethanol Dehydration

Preparation and properties of cerium modified Cu based catalysts for methanol synthesis

Production of Hydrogen by Steam Reforming of Methanol on CeO2 Promoted Cu/Al2O3 Catalysts

Characterization of Pd–CeO2/α-alumina Catalyst for Synthesis of Dimethyl Oxalate

Catalysts for Methane Steam Reforming Reaction: Evaluation of CeO2 Addition to Alumina-Based Washcoat Slurry Formulation

Coking and Deactivation Behavior Study of Ce-modified Cs-Nb/Al2O3 in Aldol Condensation of Methyl Propionate with Formaldehyde

Exploring the effect of morphology and surface properties of nanoshaped Pd/CeO2 catalysts on CO2 hydrogenation to methanol

Sol–gel-prepared ternary Ni–Ce–Mg–O oxide systems: the role of CeO2 in balancing between dry reforming of methane and pyrolysis of hydrocarbons

Synthesis-Gas Production from Methane over Ni/CeO2 Catalysts Synthesized by Co-Precipitation Method in Different Solvents

Efficient synthesis of ethylene carbonate via transesterification of ethylene glycol with dimethyl carbonate over Mg3Al1−xCexO composite oxide

Catalytic dehydration of methanol to dimethyl ether over micro–mesoporous ZSM-5/MCM-41 composite molecular sieves

Modification of Alumina and Its Application in the Direct Synthesis of Dimethyl Ether from Syngas

Efficient ceria-manganese oxide for the direct conversion of CO2 and methanol to dimethyl carbonate