On the particular burst-out and explosion features of the superfine polystyrene microsphere powder
Ming-chao BI,Jun-cheng JIANG,Jun YAO,Fei PAN
DOI: https://doi.org/10.13637/j.issn.1009-6094.2017.04.021
2017-01-01
Abstract:The given paper intends to report its experimental study results on the particular burst-out and explosion features of the superfine polystyrene microsphere powder,including the minimum ignition temperature (MIT),the maximum explosion pressure,the maximum rate of pressure increase,the minimum ignition energy(MIE) and some other indexes through a series of experimental devices,i.e.the minimum ignition temperature test device,the 20 L spherical dust explosion test device and the MIE-D1.2 test device.At the same time,we have also made a discussion over the influences of the heating temperature,the ignition delay time,the dust concentration,and the powder size on the dust explosion features.The results of our study and experiments show that it is possible to trace and observe the flameless combustion of superfine polystyrene microsphere powder even at a high temperature about 350 ℃,with the combustion starting time of the dust layer going on at higher heating temperatures with the smaller powder particles bursting on.When the dust concentration is as high as 250 g/m3,the maximum explosion pressure can likely reach 0.65 MPa,with the maximum rate of pressure going to be over 90 MPa/s in 500 g/m3.What is more,the polystyrene microspheres with their diameter of 3 μm may tend to explode when the dust concentration reaches 25 g/m3,whereas the maximum explosion index reaches 24.245 MPa · m/s,all of which implies that it would be possible to attribute its dust explosion hazards to level St2 in terms of the dust explosion hazard categorization.Furthermore,with the increase of ignition delay time,the minimum ignition energy tends to decrease slowly at first,and,then,increases abruptly on the condition when the ignition delay time is beyond 70 ms.Under the condition of low dust concentration,the larger the particle size of polystyrene microsphere is,the wider the increasing amplitude of the minimum ignition energy will be.However,when the dust concentration exceeds 500 g/m3,the microsphere particle size begins to have little effect on the minimum ignition energy,and,in turn,it would tend to get stable.And,finally,the calculation results suggest that the micro-sized superfine polystyrene microsphere powders (particle sizes are 3 μm,5 μm,10 μm,20 μm)with the MIE characterized value data of 9.2 mJ,12.9 mJ,14.1 mJ,and21.6 mJ may turn to be very much sensitive to the electrostatic spark.