Abstract:The high-quality aluminum nitride (AlN) epilayer is the key factor that directly affects the performance of semiconductor deep-ultraviolet (DUV) photoelectronic devices. In this work, to investigate the influence of thickness on the quality of the AlN epilayer, two AlN-thick epi-film samples were grown on c-plane sapphire substrates. The optical and structural characteristics of AlN films are meticulously examined by using high-resolution X-ray diffraction (HR-XRD), scanning electron microscopy (SEM), a dual-beam ultraviolet-visible spectrophotometer, and spectroscopic ellipsometry (SE). It has been found that the quality of AlN can be controlled by adjusting the AlN film thickness. The phenomenon, in which the thicker AlNn film exhibits lower dislocations than the thinner one, demonstrates that thick AlN epitaxial samples can work as a strain relief layer and, in the meantime, help significantly bend the dislocations and decrease total dislocation density with the thicker epi-film. The Urbach's binding energy and optical bandgap (Eg) derived by optical transmission (OT) and SE depend on crystallite size, crystalline alignment, and film thickness, which are in good agreement with XRD and SEM results. It is concluded that under the treatment of thickening film, the essence of crystal quality is improved. The bandgap energies of AlN samples obtained from SE possess larger values and higher accuracy than those extracted from OT. The Bose–Einstein relation is used to demonstrate the bandgap variation with temperature, and it is indicated that the thermal stability of bandgap energy can be improved with an increase in film thickness. It is revealed that when the thickness increases to micrometer order, the thickness has little effect on the change of Eg with temperature.

Fabrication of a wider bandgap θ-Al2O3 by oxidation of ultrathin AlN films for leakage current reduction

High-Performance Polycrystalline Sige Thin-Film Transistors Using Al2o3 Gate Insulators

Fabrication Process and Leakage Current Conduction Mechanisms of Al2O3 Gate Dielectric Thin Films

Growth and Characterization of Al2o3 Gate Dielectric Films by Low-Pressure Metalorganic Chemical Vapor Deposition

Leakage current reduction by thermal oxidation in Ni/Au Schottky contacts on lattice-matched In 0.18 Al 0.82 N/GaN heterostructures

Investigation of oxidation for high quality Nb/AlOx-Al/Nb Josephson tunnel junctions

Fabrication and Application of Nano-Porous Aluminum

Effect of AlN interlayer thickness on leakage currents in Schottky contacts to Alo.25Gao.75N/AlN/GaN heterostructures

Understanding Leakage Currents through $Al_2O_3$ on $SrTiO_3$

Demonstration of aluminum nitride metal oxide semiconductor field effect transistor on sapphire substrate

Enhanced Device Performance of AlGaN/GaN HEMTs Using Thermal Oxidation of Electron-Beam Deposited Aluminum for Gate Oxide

Inhibiting the Formation of Planar Defects in Grown Alumina Scale on Ni-Al Alloys

High-temperature operation of Al2O3/Ga2O3 bi-layer gate stack GaN MOS-HEMT up to 450 °C with suppressed gate leakage

Fabrication of Aln Thin Films on Different Substrates at Ambient Temperature

Optical and Structural Properties of Aluminum Nitride Epi-Films at Room and High Temperature

Experimental Evidence Of Large Bandgap Energy In Atomically Thin Aln

Leakage properties of BaTiO 3 thin films on polycrystalline Ni substrates grown by polymer-assisted deposition with two-step annealing

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al<sub>2</sub>O<sub>3</sub> Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

Nucleation Effects in the Atomic Layer Deposition of Nickel–Aluminum Oxide Thin Films

Pulsed Laser Deposition of Aluminate YAlO 3 and LaAlO 3 Thin Films for Alternative Gate Dielectric Applications