Abstract:For preparation of transparent conductive oxide (TCO)/metal/TCO tri-layer films, Cu and Ga-doped ZnO (GZO) films were respectively used as the metal and TCO layers and were deposited by magnetron sputtering at room temperature. The effect of film thickness on transparent conductive properties of single Cu films was first investigated in order to better understand the properties of tri-layer films. The results show that the resistivity, sheet resistance (R-s), average transmittance in visible light range (T(Vi)s), and figure of merit (FOM) of Cu films decrease with increasing film thickness. The investigations of effect of H-2 flux on the transparent conductive properties of GZO films show that hydrogenated GZO (HGZO) films have lower resistivity and higher TVis than those of GZO films. On basis of the investigation of single Cu and GZO films, the GZO/Cu/GZO (GcG) and HGZO/Cu/HGZO (HcH) tri-layer films were prepared, and their transparent conductive properties were investigated as a function of Cu and GZO (or HGZO) layer thickness. The results show that these two kinds of tri-layer films have the best FOM at Cu layer thickness of 7 nm and GZO (or HGZO) layer thickness of 40 nm. Compared with GcG tri-layer films, HcH tri-layer films have better FOM, indicating that introducing H-2 into sputtering atmosphere plays a significant role on the transparent conductive properties of the tri-layer films. In addition, bandgap (E-g) of single GZO and tri-layer films was discussed as a function of carrier concentration in the paper.

Improved deposition of ZnO:Ga thin films by sputtering with the chamber pressure

Limiting factor for electron mobility in sputtered Ga-doped ZnO thin films

Influence of Sputtering Pressure on the Properties of ZnO:Ga Films Prepared by DC Reactive Magnetron Sputtering

Preparation and Characterization of Transparent Conductive Zno : Ga Films by Dc Reactive Magnetron Sputtering

Deposition and Characterization of AZO Thin Films on Flexible Glass Substrates Using DC Magnetron Sputtering Technique

Microstructure and Optical Properties of ZnO Films Deposited by Radio-frequency Reactive Magnetron Sputtering

Influence of O_2/Ar Flow Ratio on Microstructures and Photoluminescence of ZnO Films

Optimization of parameters for deposition of Ga-doped ZnO films by DC reactive magnetron sputtering using Taguchi method

Transparent and conductive Ga-doped ZnO films grown by RF magnetron sputtering on polycarbonate substrates

Influences of the RF power ratio on the optical and electrical properties of GZO thin films by DC coupled RF magnetron sputtering at room temperature

Deposition and Characterization of Sputtered ZnO Films

Effects of Sputtering Pressure on Properties of Al Doped Zno Thin Films Dynamically Deposited by Rf Magnetron Sputtering

Improvement of Transparent Conductive Properties of GZO/Cu/GZO Tri-Layer Films by Introducing H2 into Sputtering Atmosphere

Effects of Gas Parameters on Properties of In2O3 Thin Films Deposited by Magnetron Sputtering

Simultaneous enhancement of electrical conductivity, uniformity, and near-infrared transmittance via laser annealing on ZnO:Ga films deposited by atmospheric pressure plasma jet

Investigation of ZnO∶Al Thin Films Deposited by RF Magnetron Sputtering

High optoelectronic performance of magnetron sputtered ZnO thin films co-doped with F and Ga: Experiment and first-principles calculations

Electrical Transport Property of ZnO Thin Films in High H2 Pressure up to 20 bar

F, Mg and Ga co-doped ZnO transparent conductive thin films by dual-target magnetron sputtering: Fabrication, structure, and characteristics

Surface morphology of ZnO buffer layer and its effects on the growth of GaN films on Si substrates by magnetron sputtering

Effects of Post-Annealing on the Properties of ZnO:Ga Films with High Transparency (94%) and Low Sheet Resistance (29 Ω/square)