Abstract:The gallium–magnesium codoped zinc oxide (GMZO) thin films were deposited on glass substrates by radio frequency magnetron sputtering technique in an argon atmosphere. The influence of substrate temperature on the microstructure, morphology and optoelectronic properties of thin films was investigated by X-ray diffraction, scanning electron microscopy, X-ray photoelectron spectroscopy, four-point probe and spectrophotometry. It is found that all the deposited films have a hexagonal structure and a preferred orientation along the c-axis perpendicular to the substrate. As the substrate temperature increases, the dislocation density, lattice strain and electrical resistivity decrease initially and then increase, while the average crystallite size, average visible transmittance and figure of merit exhibit the reverse variation trend. The GMZO thin film deposited at the substrate temperature of 570 K possesses the best optoelectronic properties, with the largest average crystallite size of 52.05 nm, the lowest dislocation density of 3.69 × 1014 lines m− 2, the minimum lattice strain of 1.10 × 10− 3, the lowest electrical resistivity of 1.62 × 10− 3 Ω cm, the highest average visible transmittance of 88.63% and the maximum figure of merit of 5.11 × 103 Ω−1 cm− 1. The optical energy gaps of the films were evaluated by extrapolation method and observed to be in the range of 3.34–3.55 eV. Furthermore, the complex refractive index, the complex dielectric constant and the dissipation factor were determined by optical characterization methods, and the dispersion behaviour of refractive index was studied in terms of the single electronic oscillator model. The results show that the microstructure and optoelectronic properties of the GMZO thin films are dependent on substrate temperature.

F, Mg and Ga co-doped ZnO transparent conductive thin films by dual-target magnetron sputtering: Fabrication, structure, and characteristics

High optoelectronic performance of magnetron sputtered ZnO thin films co-doped with F and Ga: Experiment and first-principles calculations

Preparation and Characterization of Mg-doped ZnO Thin Films by Sol–gel Method

Ga, Mg, F ternary-doped ZnO-based transparent conductive film prepared by radio-frequency sputtering with high transmittance

Microstructue and Optical Properties of Mg-doped ZnO Thin Films Prepared by Sol-gel Method

Effect of Magnesium Doping on the Light-Induced Hydrophilicity of Zno Thin Films

Transparent and conductive Ga-doped ZnO films grown by RF magnetron sputtering on polycarbonate substrates

Radio frequency magnetron sputtering deposition of low-resistivity and broad-spectral transmission F and Al co-doped ZnO film with mobility exceeding 50 cm2 V−1 s−1

Optical and Electrical Properties of the Different Magnetron Sputter Power 300°C Deposited -ZnO Thin Films and Applications in p-i-n -Si:H Thin-Film Solar Cells

Fluorine, chlorine, and gallium co-doped zinc oxide transparent conductive films fabricated using the sol-gel spin method

Structural and Magnetic Properties of Co–Ga Co-Doped ZnO Thin Films Fabricated by Pulsed Laser Deposition

Effects of Mg Doping on the Properties of Highly Transparent Conductive and Near Infrared Reflective Zn1−xMgxO:Ga Films

Ga-concentration-dependent optical and electrical properties of Ga-doped ZnO thin films prepared by low-temperature atomic layer deposition

Tailoring of the Structural, Optical, and Electrical Characteristics of Sol-Gel-Derived Magnesium-Zinc-Oxide Wide-Bandgap Semiconductor Thin Films via Gallium Doping

Highly Conducting and Wide-Band Transparent F-doped Zn1−xMgxO Thin Films for Optoelectronic Applications

Microstructure and optoelectronic properties of gallium–magnesium codoped zinc oxide thin films by magnetron sputtering technique

Influences of the RF power ratio on the optical and electrical properties of GZO thin films by DC coupled RF magnetron sputtering at room temperature

Microstructure, Optical and Photoluminescence Properties of Ga-doped ZnO Films Prepared by Pulsed Laser Deposition

Transparent conductive ZnO:Ga films prepared by DC reactive magnetron sputtering at low temperature

Influence of RF power on the opto-electrical and structural properties of gallium-doped zinc oxide thin films

Improvement of Transparent Conductive Properties of GZO/Cu/GZO Tri-Layer Films by Introducing H2 into Sputtering Atmosphere