Abstract:Al2O3, as one of the gate dielectric materials for thin film transistors (TFTs), has been extensively investigated because of its large bandgap, high breakdown field, and good thermal stability. However, the further development of Al2O3 thin films is limited by the presence of defects such as oxygen vacancies, self-interstitial atoms, or impurity elements. To overcome this obstacle, we have developed a novel method for fabricating Al2O3 thin films by using the atomic layer deposition (ALD) technique. This method replaces the conventional Trimethylaluminium (TMA)/H2O cycles with TMA/TMA/H2O/H2O cycles (referred to as ‘double cycles’), to deposit the Al2O3. The 5-nm ultrathin Al2O3 film showed a high areal capacitance of 660 nF/cm2 at 20 Hz, and a relatively low current density of 10−8 A/cm2 at 1 MV/cm. InGaZnO (IGZO) TFTs with ultrathin Al2O3 gate dielectric grown by double cycles exhibited outstanding performances, such as a near theoretical limit subthreshold swing (SS) of 70 mV/decade, a higher on/off current ratio $(I_{\mathrm{ on}} / I_{\mathrm{ off}}$ ) of 106, an increased field-effect mobility ( $\mu $ ) of 6.5 cm2/Vs, a lower threshold voltage $(V_{\mathrm{ th}})$ of 0.2 V, and a low operating voltage of 3 V. These results are superior to the IGZO TFTs with Al2O3 dielectrics deposited using the single TMA/H2O cycle. Therefore, the implementation of ‘double cycles’ in the fabrication of dielectrics through ALD demonstrates considerable potential for future application in low-power electronic devices.

Solution-processed amorphous gallium oxide gate dielectric for low-voltage operation oxide thin film transistors

High-Performance Polycrystalline Sige Thin-Film Transistors Using Al2o3 Gate Insulators

Aqueous solution-deposited aluminum-gallium-oxide alloy gate dielectrics for low voltage fully oxide thin film transistors

Aqueous-solution-synthesized gallium oxide dielectrics for high-mobility thin-film transistors enhanced by phosphorus incorporation

Solution-processed amorphous gallium-tin oxide thin film for low-voltage, high-performance transistors

Low-Voltage a-InGaZnO Thin-Film Transistors With Anodized Thin HfO 2 Gate Dielectric

Aqueous Solution Derived Amorphous Indium Doped Gallium Oxide Thin-Film Transistors

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al<sub>2</sub>O<sub>3</sub> Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al2O3 Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

Influence of indium doping on electrical performance of gallium oxide thin-film transistors

Low-Temperature Solution-Processed Zirconium Oxide Gate Insulators for Thin-Film Transistors

Atomic Layer Deposition of Gallium Oxide Films as Gate Dielectrics in AlGaN/GaN Metal-Oxide-Semiconductor High-Electron-Mobility Transistors

High-Performance Amorphous InGaZnO Thin Film Transistor With High-k Van Der Waals Molecular Dielectric

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al₂O₃ Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

4 inch Gallium Oxide Field‐Effect Transistors Array with High‐k Ta2O5 as Gate Dielectric by Physical Vapor Deposition

Chemical and Electrical Properties of Low-Temperature Solution-Processed In–Ga–Zn-O Thin-Film Transistors

Solution-Processed Zirconium Oxide Gate Insulators for Top Gate and Low Operating Voltage Thin-Film Transistor

Transparent Amorphous Indium-Gallium-Zinc-Oxygen Thin Film Transistors Using Solution Technology at Low Temperature

High-Performance Amorphous InGaZnO Thin-Film Transistor Gated by HfAlOₓ Dielectric with Ultralow Subthreshold Swing

Ultra-thin gate insulator of atomic-layer-deposited AlO x and HfO x for amorphous InGaZnO thin-film transistors

Aluminum Oxide/Fluoride Self-Assembled Monolayer Double Gate Dielectric for Solution-Processed Indium Oxide Thin-Film Transistors