Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

Effects of gate material on Fowler-Nordheim stress induced thin silicon dioxide degradation under negative gate bias

Gate Bias and Length Dependences of Total Ionizing Dose Effects in InGaAs FinFETs on Bulk Si

Effects of Positive and Negative Stresses on III-V MOSFETs With Al2O3 Gate Dielectric

Total-Ionizing-Dose Effects and Low-Frequency Noise in 30-Nm Gate-Length Bulk and SOI FinFETs with SiO2/HfO2Gate Dielectrics

Improving the reliability of MOS capacitor on 4H-SiC (0001) with phosphorus diffused polysilicon gate

Gate Oxide Reliability in Silicon Carbide Planar and Trench Metal-Oxide-Semiconductor Field-Effect Transistors Under Positive and Negative Electric Field Stress

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

Effects of Positive and Negative Stresses on III–V MOSFETs With Gate Dielectric

Analysis of Gate Oxide Degradation Induced by Heavy Ion in SiC Power MOSFETs

Impact of Gate Materials on Positive Charge Formation in HfO2∕SiO2 Stacks

Gate Oxide Reliability and VTH Stability of Planar SiC MOS Technology

Total Ionizing Dose Effects of Si Vertical Diffused MOSFET with SiO2 and Si3N4/SiO2 Gate Dielectrics

Effect of Gate Voltage Stress on InGaAs MOSFET with HfO 2 or Al 2 O 3 Dielectric

Oxide Electric Field-Induced Degradation of SiC MOSFET for Heavy-Ion Irradiation

The characteristics of leakage current mechanisms and SILC effects of Al 2 O 3 gate dielectric

Effects of High Gate Voltage Stress on Threshold Voltage Stability in Planar and Trench SiC Power MOSFETs

Degradation of polycrystalline HfO<sub>2</sub>-based gate dielectrics under nanoscale electrical stress

Positive Bias Temperature Instability Degradation of InGaAs N-Mosfets with Al2O3 Gate Dielectric

Comprehensive Stress Effect of Thin Coatings and Silicon-Carbon Lattice Mismatch on Nano-Scaled Transistors with Protruding Poly Gate

Growth and Characterization of Al2o3 Gate Dielectric Films by Low-Pressure Metalorganic Chemical Vapor Deposition

Gate Oxide Reliability Degradation by Post Poly-Silicon Annealing and Suppression Method