Abstract:In this article, we present an experimental study on the impact of post-metallization annealing conditions on the negative-bias temperature instability (NBTI) of Si p-channel fin field-effect transistors (p-FinFETs) with atomic layer deposition tungsten (ALD W) as the gate-filling metal. The effects of annealing conditions on the tensile stress of the W film, impurity element concentration in the gate stack, fresh interface quality, threshold voltage shift ( ${\Delta }$ V $_{T}$ ), pre-existing traps ( ${\Delta } {N} _{\mathrm {HT}}$ ), generated traps, and their relative contributions were studied. The time exponents of ${\Delta }$ V $_{T}$ , the impacts of stress bias and temperature on NBTI degradation, and the recovery kinetics of the generated traps were analyzed. For devices with a B2H6-based W-filling metal, a 34% reduction in the fresh interface states, reduced ${\Delta }$ V $_{T}$ , and a 29% improvement in the operation overdrive voltage could be achieved by optimizing the annealing conditions. The NBTI is alleviated mainly because of the reduction in the generated traps, while the energy distribution of ${\Delta } {N} _{\mathrm {HT}}$ is insensitive to the annealing conditions. Furthermore, the relative contribution of the generated bulk insulator traps to the total number of generated traps could be reduced by optimizing the annealing conditions.

Impact of Hf content on negative bias temperature instabilities in HfSiON-based gate stacks

Negative bias temperature instability of HfN/HfO2 gated p-MOSFETs

Impact of Gate Materials on Positive Charge Formation in HfO2∕SiO2 Stacks

Modulation of Interfacial and Electrical Properties of ALD-derived HfAlO/Al2O3/Si Gate Stack by Annealing Temperature

Impact Of Different Defects On The Kinetics Of Negative Bias Temperature Instability Of Hafnium Stacks

Dominant Layer for Stress-Induced Positive Charges in Hf-Based Gate Stacks

Impact of Sensing Gate Bias on NBTI of Hf-based Dielectric Stacks

Threshold Voltage Instability of P-Channel Metal-Oxide-Semiconductor Field Effect Transistors with Hafnium Based Dielectrics

Bias Temperature Stress Induced Hydrogen Depassivation from Al2O3/InGaAs Interface Defects

Fluorine IMP effect on negative bias temperature instability and process induced defects

Alleviation of Negative-Bias Temperature Instability in Si P-Finfets with ALD W Gate-Filling Metal by Annealing Process Optimization

Revealing the Positive Bias Temperature Instability in Normally-OFF AlGaN/GaN MIS-HFETs by Constant-Capacitance DLTS

Poststress Recovery Mechanism Of The Negative Bias Temperature Instability Based On Dispersive Transport

Hydrogen-Related Instability of IGZO Field-Effect Transistors

Mechanism of positive-bias temperature instability in sub-1-nm TaN/HfN/HfO2 gate stack with low preexisting traps

Process-Induced Positive Charges in Hf-Based Gate Stacks

Investigation of an Anomalous Hump in Gate Current after Negative-Bias Temperature-Instability in Hfo2/Metal Gate P-Channel Metal-Oxide-Semiconductor Field-Effect Transistors

High bias stability of Hf-doping-modulated indium oxide thin-film transistors

The Influence of the Hafnium Doping on Negative Bias Stability in Zinc Oxide Thin Film Transistor

Negative Bias Temperature Instability (NBTI) in Deep Sub-Micron P/sup +/-Gate Pmosfets