Abstract:With heightened concerns for the clean air and clean environment, hydrogen energy derived from renewable sources in conjunction with fuel cell has recently been under investigation actively. Producing hydrogen from steam reforming of ethanol is considered as a preferred method. Ni-based catalyst is highly recommended in this process while the oxide supports play an important role on its selectivity and stability. Researches in the nanomaterials recently have revealed that catalytic nanoarchitecture with comparably sized metal and oxide domains can retain high activity because of an increase the interfacial contact area and hindering agglomeration of the active metal. It opens a new route in the development of highly active and stable catalysts for the steam reforming process. Here we present primary study on the impacts of zirconia particle size on the catalytic behavior of nanocomposite Ni-ZrO2 catalysts in the steam reforming of ethanol. Three nanocomposite Ni-ZrO2 catalysts with particle sizes of zirconia concentrated at 50 nm, 25 nm and 15 nm were carefully prepared by precipitation followed by impregnation method and nominated here as Ni-ZrO2-50, Ni-ZrO2-25 and Ni-ZrO2-15 respectively. The average nickel particle sizes in the first two catalysts were about 62 nm and 23 nm after reduction. To better understand the size effect of zirconia support, the Ni-ZrO2-15 catalyst underwent specially treated to enlarge the nickel particles to 80 nm in the reduced samples. The impact of weight flow rate on the catalytic activity was investigated at 400 °C, ethanol/H2O = 1:3 for all the three catalysts. The catalysts showed complete conversion of ethanol at W/F higher than 2.0×10-4 (gcat h)/ml but dropped in an order of Ni-ZrO2-50, Ni-ZrO2-15 and Ni-ZrO2-25 catalysts in the reverse direction, indicating different activities of the catalysts. Analysis of the selectivity towards different carbonous compounds in the reactions operating at condition range that incomplete conversion of ethanol was achieved reveals clue in the reaction pathway of different catalysts, in which a main route of ethanol undergoing dehydrogenation to produce acetaldehyde followed by decomposition of acetaldehyde into CO and CH4 was found for all the three catalysts. Besides, trace of acetone and ethylene were also detected in the product stream of the Ni-ZrO2-50 and Ni-ZrO2-15 catalysts while little was found for the Ni-ZrO2-25 catalyst under the reaction condition range studied here. In ethanol steam reforming, acetaldehyde could also be oxidized into acetic acid and further transform into acetone by ketonization reaction, which could lead to unfavorable coke deposition on the surface of the support. Zirconia is reported to have high surface oxygen mobility especially in tetragonal phase when comparing with monoclinic phase. In the Ni-ZrO2-15 catalyst with a reduced zirconia particle size under the size limitation, predominant tetragonal phase along with trace of monoclinic phase of zirconia were detected in the XRD analysis while only a single monoclinic phase of zirconia was detected in the reduced Ni-ZrO2-50 and Ni-ZrO2-25 catalysts. The increase of oxidation activity due to the reduction of zirconia particle size has led to a higher selectivity towards acetone formation in the ethanol steam reforming for Ni-ZrO2-15 catalyst. In spite of the improvement in oxidation activity of the catalyst, the reduction in particle size of zirconia would not have significant positive impact on the catalytic activity unless the particle size of the nickel metal is also reduced into a limited range. Although the zirconia and the nickel particles are in a comparable range, 50 nm seems to be too large for the Ni-ZrO2-50 catalyst to perform a good activity in the steam reforming of ethanol. Reducing the particle of zirconia while keeping the nickel metal particle size in a range of larger than 50 nm, as in the situation of the Ni-ZrO2-15 catalyst, the improvement in the catalytic activity could only be in a limited range since insufficient C-C bond cleavage activity is supplied by the nickel metal. When both of the particle sizes of the zirconia and the nickel metal are reduced into a suitable range as in the situation of the Ni-ZrO2-25 catalyst, the increase of metal support interaction as revealed in the H2-TPR profiles lead to a significant improvement in both the activity and selectivity of the catalyst.

Effect of Nickel Loading on the Production of Hydrogen Via Ethanol Steam Reforming

Ethanol Steam Reforming over Ni/NixMg1−xO: Inhibition of Surface Nickel Species Diffusion into the Bulk

Magnesium Promoted Hydrocalumite Derived Nickel Catalysts for Ethanol Steam Reforming

Hydrogen production from ethanol steam reforming over nickel based catalyst derived from Ni/Mg/Al hydrotalcite-like compounds

Impacts of Nickel Loading on Properties, Catalytic Behaviors of Ni/γ–Al2O3 Catalysts and the Reaction Intermediates Formed in Methanation of CO2

Synergy Effect of MgO and ZnO in a Ni/Mg–Zn–Al Catalyst During Ethanol Steam Reforming for H2-rich Gas Production

Effect of Ni loadings on the catalytic properties of Ni/MgO(111) catalyst for the reforming of methane with carbon dioxide

Ni-hydrocalumite Derived Catalysts for Ethanol Steam Reforming on Hydrogen Production

Effect of Promoter Mg on Ni/γ-Al_2O_3 Catalyst for Methane Autothermal Reforming

Effect of NiO on the Catalytic Performance of Au/TiO_2 Catalyst for Hydrogen Production from Methanol Steam Reforming

Hydrogen Production by Steam Reforming of Ethanol and Dry Reforming of Methane with CO2 on Ni/Vermiculite: Stability Improvement via Acid or Base Treatment of the Support

Hydrogen production via glycerol steam reforming over Ni/Al 2O3: Influence of nickel precursors

Syngas production employing nickel on alumina‐magnesia supported catalyst via dry methane reforming

Highly Dispersed Ni/Montmorillonite Catalyst for Glycerol Steam Reforming: Effect of Ni Loading and Calcination Temperature

Hydrogen Production by Ethanol Steam Reforming on Nicumgal Catalysts Derived from Hydrotalcite-Like Precursors

Nanocomposite Ni-ZrO2 catalysts for ethanol steam reforming: Effect of support size on the catalytic behavior

Influence of Preparation Conditions of Ni/Al_2O_3 Catalyst on Its Activity in ydrogen Production by Ethanol Steam Reforming

Ethanol Steam Reforming over Ni-Cu/Al2O3-MyOz (M = Si, La, Mg, and Zn) Catalysts

Effect of Ca and Co over Ni–Al Mixed Oxides for Hydrogen Production by Ethanol Steam Reforming

Ni/SBA-15 Catalysts for Hydrogen Production by Ethanol Steam Reforming: Effect of Nickel Precursor

Ni Supported on MgO Modified Attapulgite As Catalysts for Hydrogen Production from Glycerol Steam Reforming