Abstract:With the development of the ultra-large scale integrated circuit (ULSI) technology, CoSi2 has become a leading candidate for contact materials in electronic devices due to its linewidth-independent low resistivity and small lattice mismatch with Si substrate [1]. Among many methods to fabricate epitaxial CoSi2 films, solid phase epitaxy (SPE) is a very important one [2]. Ti-interlayer mediated epitaxy (TIME) [3] and oxide mediated epitaxy (OME) [4] can be regarded as improvements of SPE. In SPE, the Co film is usually deposited at room temperature and the as-deposited Co films are usually amorphous [2, 5]. During low temperature annealing, the crystallization of Co film can be observed; yet during high temperature annealing, especially rapid thermal annealing (RTA), this process cannot be observed [5]. So in high temperature RTA, we cannot tell whether the Co film has undergone crystallization before the formation of silicides. This fact suggests that the formation of silicides during high temperature RTA may be the result of the reaction between amorphous Co film and Si substrate, not the reaction between crystalline Co film and Si substrate. Based on this consideration, we expect the reaction between real crystalline Co film and Si substrate to produce some results different from previous reports. Si(111) substrate was chosen because the epitaxial growth of CoSi2 film on Si(111) is not so complicated as that on Si(100). The purpose of this letter is to study the reaction between crystalline Co film and Si(111) substrate. n-Typed Si(111) with a resistivity of 4‐4.8� · cm were ultrasonically cleaned in acetone, rinsed in deionized water, etched in HF : H2O2(1 : 1), rinsed in deionized water again, and then loaded into the e-gun evaporation system. The base pressure of the system was 1.2 × 10 −8 Torr. During the deposition process, the vacuum level was 2.3 × 10 −7 Torr. Crystalline Co films of 150 nm thickness were obtained by heating the substrate to 150 ◦ C during the e-gun evaporation. Subsequent ex situ RTA was carried out in a high vacuum of 3.0 × 10 −6 Torr at temperatures between 470 and 850 ◦ C for 3 min. X-ray diffraction (XRD) was used to investigate the phases and their preferential orientations formed during the Co-Si reaction. The composition of the film was analyzed by auger electron spectroscopy(AES) and the crystalline properties of CoSi2 films were evaluated by reflection high-energy electron diffraction (RHEED).

Ca_2Si crystal grown selectively by R. F. MS

EPITAXIAL GROWTH OF (0001)ORIENTED 6H-Sic FILMS ON Si(111) SUBSTRATE BY ORGANIC SOL-GEL FILM ANNEALING

Growth of Crystalline SiC Film Free of Cavities by Heating PS/silica Sol-Gel Coatings on Si (111) Substrate

Growth of Si-C-H film by RF plasma enhanced chemical vapor deposition

Growth and Mechanical Properties of Amorphous and Nanostructured SiC films

Study of Crystallization and Phase Transformation in Amorphous Co-Si Thin Film by X-Ray Diffraction

Microstructure Evolution of Si Nanocrystals in Si/C Multilayer Films

Solid phase reaction between crystalline, (002) oriented Co film and Si(111) substrate: Preferential orientations of silicides

Microstructure and Conductivity of Large Area Nanocrystalline Silicon Films Grown by Specially Designed Thermal-Assisted Chemical Vapor Deposition

Microstructure and Electrical Characteristics of Cr–Si–Ni Films Deposited on Glass and Si (100) Substrates by RF Magnetron Sputtering

Growth of Poly-Crystalline Si Films on Flexible Substrate by Hot Wire Chemical Vapor Deposition

Structure and photoluminescence properties of SiC films synthesized by the RF-magnetron sputtering technique

Precipitation and Crystallization of Nanometer Si Clusters in Annealed Si-Rich Sio2 Films

Study on the solid state reaction between crystalline Co film and Si(1 1 1) substrate

Growth of SiC Thin Films on (100) and (111) Silicon by Pulsed Laser Deposition Combined with a Vacuum Annealing Process

Thermal effect on RF sputtered SiC film

Study on 3C-Sic/si(111) by X-Ray Grazing Incident Diffraction

The Crystallization of Cr–Si–Ni–Al Amorphous Films—nucleation and Growth of Intermetallic Phase Cr(Al,Si)2

Synthesis and Characterization of Crystalline Films on Silicon

Growth of epitaxial CoSi2 films on Si(1 0 0) substrates through direct solid phase reaction between crystalline Co films and Si substrates

Crystallization of As-Deposited Amorphous Silicon Films on Glass Prepared by Magnetron Sputtering with Different Substrate Biases and Temperatures