Abstract:The effects of CO2 on the selective formation of i-C4 hydrocarbons (isobutene and isobutane) from CO2/CO/H2 reactant mixtures were studied. Three ZrO2-based catalysts including unmodified ZrO2, 8.6%Y2O3-ZrO2, and 15.3%Al2O3-0.5%K2O-ZrO2, were used in this study. The catalysts were characterized by N2 adsorption, X-ray diffraction (XRD), Raman, spectra, temperature-programmed desorption (TPD) of ammonia and carbon dioxide, and temperature-programmed reduction (TPR). The influences of CO2 on the catalytic performances of the catalysts were investigated by varying the content of CO2 in the feed up to 20%. It was found that the addition of CO2 in the synthesis gas (CO/H2) significantly reduced the net formation of CO2, but did not affect the formation of hydrocarbons. For the distribution of hydrocarbons, the selectivity to i-C4 in total hydrocarbons decreased with increasing the content of CO2 in the feed, while the selectivities to C1–C3 hydrocarbons increased. However, the i-C4 selectivities in all products were enhanced significantly because of the inhibition of CO2 formation with CO2 adding in the feed. The predominant products in CO2 hydrogenation on the ZrO2-based catalysts were CO and H2O at 648–723K, indicating that the ZrO2-based catalysts were not active in the reactions towards hydrocarbons from CO2/H2. A 5–6% yield of i-C4 hydrocarbons with ∼62% selectivity in the products was achieved on 15.3%Al2O3-0.5%K2O-ZrO2 catalyst at 8–9% CO conversion with 20% CO2 adding in the feed at 698K. The yield of CO2 was only 0.5% (∼5% CO2 selectivity in the products). Our results would suggest one potential way of using the recycle of CO2 formed to selectively synthesize i-C4 hydrocarbons from coal or natural gas-derived syngas (CO+H2) with high carbon efficiency (with free or very low CO2 emission).

Synthesis Of Iso-C-4 And Dimethyl Ether From Syn-Gas Over Superfine Zirconia Catalysts

Synthesis of isobutene from synthesis gas over nanosize zirconia catalysts

C2–C4 Hydrocarbons Synthesis from Syngas over CuO–ZnO–Al2O3/SAPO‐34 Bifunctional Catalyst

The Effects of the Crystalline Phase of Zirconia on C–O Activation and C–C Coupling in Converting Syngas into Aromatics

Synthesis of mesoporous molecular sieves and their application as supports for catalysts in F-T synthesis

Synthesis of iso-C4 hydrocarbons from CO hydrogenation over Pr6O11 and Pr-Zr-O composite oxide catalysts

Complete liquid-phase preparation and characterization of Cu-Zn-Al-Zr slurry catalysts for synthesis of dimethyl ether

Catalytic oxidation of isoamyl alcohol on modified ZSM-5 molecular sieve catalysts prepared by different methods

Synthesis and Surface Characteristics of Zirconia and Modified Zirconia: Performance of CO Hydrogenation

Selective Formation of Isobutene from Co Hydrogenation over Zirconium Dioxide Based Catalysts

Single-Step Synthesis of Dimethyl Ether from Biomass-Derived Syngas over Cuo-Zno-Mox (M = Zr, Al, Cr, Ti)/Hzsm-5 Hybrid Catalyst: Effects of Mox

Surface active structure of ultra-fine Cu/ZrO2 catalysts used for the CO2+H2 to methanol reaction

Direct Synthesis of Dimethyl Carbonate from Methanol and CO2 over ZrO2 Catalysts Combined with a Dehydrating Agent and a Cocatalyst

Preparation and properties of ultrafine SO4 2- /ZrO2 superacid catalysts

Dimethyl Ether Synthesis from Co2 Hydrogenation over Cuo-Tio2-Zro2/Hzsm-5 Catalysts

Highly Efficient Synthesis of Dimethyl Ether from Syngas over the Admixed Catalyst of CuO–ZnO–Al2O3 and Antimony Oxide Modified HZSM-5 Zeolite

Erratum to “Influence of reactor materials on i-C4 synthesis from CO hydrogenation over ZrO2 based catalysts” [Fuel Process. Technol. 83 (1–3) (2003) 39–48]

Study on Catalyst C207-HZSM-5 for Dimethyl Ether Synthesis

Preparation and Properties of Ultrafine SO42−/ZrO2 Superacid Catalysts

Effects of CO2 on synthesis of isobutene and isobutane from CO2/CO/H2 reactant mixtures over zirconia-based catalysts

Synthesis of isobutene from CO hydrogenation over nanosized zirconium dioxide-based catalysts