Abstract:Dimethyl carbonate (DMC) is a promising green chemical that plays a significant role in the sustainable chemical industry, clean energy technologies, and environmental protection. In response to the challenges of high equipment investment and energy consumption in the existing process for producing dimethyl carbonate through an ester exchange reaction using vinyl carbonate and methanol, a new reactive dividing-wall column (RDWC) process was developed. A new RDWC model was established by using Aspen Plus. The impact factors of reaction conditions such as reactant molar ratio, theoretical number of reaction stages, reaction pressure, and separation conditions such as theoretical number of common rectifying section, theoretical number of common stripping section, liquid phase distribution on both sides of the dividing wall, and side draw location were analyzed. A laboratory-scale new RDWC was designed and built referenced to the simulation results. The experimental research investigated key parameters affecting the reaction distillation column, such as the reaction zone height, reactant molar ratio, liquid phase distribution, reflux ratio, and vapor phase distribution on both sides of the dividing wall. This research laid the foundation for the scale-up designing of process parameters for the new RDWC. Under optimized conditions, the conversion rate of reactant EC (ethylene carbonate) exceeded 99.9%, the purity of methanol in the side draw was at least 99 wt %, and the purity of methanol ethylene glycol in the distillation column achieved a concentration greater than 99% (excluding the catalyst). The new method can greatly shorten the transesterification process (integrate the three towers in the original process into one) to produce dimethyl carbonate, save investment, and reduce energy consumption.

Progress in the One-Step Mass Production of Dimethyl Ether Using Circulating Slurry Reactors

One-step Synthesis of Dimethyl Ether from Semi-water Gas for Industrial Trial Production

Highly Efficient Production of 5-Methoxymethylfurfural from Fructose in Dimethyl Sulfoxide/Amberlyst-15 Catalytic System

A near-zero carbon emission methanol production through CO2 hydrogenation integrated with renewable hydrogen: Process analysis, modification and evaluation

Direct mass production technique of dimethyl ether from synthesis gas in a circulating slurry bed reactor

Research Progress on Seperation Process for One-step Synthesis of Dimethyl Ether from Syngas

One-Pot Synthesis of Dimethyl Carbonate from Methanol, Propylene Oxide and Carbon Dioxide Over Supported Choline hydroxide/MgO

Experimental study of improved two step synthesis for DME production

One-step synthesis of dimethyl ether from biomass-derived syngas on CuO-ZnO-Al2O3/HZSM-5 hybrid catalyst: Combination method, synergistic effect, water-gas shift reaction and catalytic performance

A novel energy-efficient process of converting CO2 to dimethyl ether with techno-economic and environmental evaluation

Study on synthesis of dimethyl ether from syngas obtained by biomass gasification

Synthetic fuels and chemicals production from biomass synthesis gas

Process design and downstream optimization of the direct synthesis route for cleaner production of dimethyl ether from biogas

Slurry Reactors For Gas-To-Liquid Processes: A Review

Single-step dimethyl ether synthesis on a Cu/ZnO/Al_2O_3/ZrO_2+γ-Al_2O_3 bifunctional catalyst in slurry reactor

Complete liquid-phase preparation and characterization of Cu-Zn-Al-Zr slurry catalysts for synthesis of dimethyl ether

Recent Progress in Methanol‐to‐Olefins (MTO) Catalysts

Study on a New Reactive Dividing-Wall Column for the Reaction of Vinyl Carbonate and Methanol Ester Exchange to Produce Dimethyl Carbonate

Sludge deep dewatering by liquefied dimethyl ether: selection of operating conditions based on response surface methodology

Catalytic performance of CuZnAl slurry catalyst prepared by complete liquid phase technology for direct synthesis DME from syngas

Thermodynamic Optimization of Dimethyl Ether Synthesis from Syngas in Polygeneration Systems