Abstract:Recent decades have seen a growing concern about ever-increasing green house gas (GHG) emissions and depletion of fossil fuels. Polygeneration, a multi-input multi-output energy system, provides huge opportunities to tackle these problems due to its superior performances over conventional energy systems in terms of energy conversion efficiency and GHG emissions. Many approaches have been made in process design and analysis of polygeneration energy systems, but most of them focus on using coal gasification as the only way to provide gas for downstream utilization. Coke oven gas, another gas source with huge capacity, however, has not received enough attention in polygeneration process design, and researches in this field are still rather limited. In this paper, we present a dual-gas sourced polygeneration process design which uses both gasification gas and coke oven gas and produces methanol, dimethyl ether (DME), and dimethyl carbonate (DMC) in an integrated catalysis procedure. Gasification gas and coke oven gas are converted to synthesis gas, or syngas, via a catalytic reforming procedure, where the ratio between carbon monoxide and hydrogen in the syngas is carefully adjusted according to specific requirements of downstream chemical synthesis reactions. An integrated catalysis procedure follows, where DME is synthesized from the fresh syngas first, unconverted syngas is then sent to a methanol synthesis unit to produce methanol, and part of the methanol is further converted to DMC in a DMC synthesis unit. Based on the proposed process design, an exergoeconomic analysis and an exergy cost distribution diagram are presented, from which the production cost of a product over each functional block of the process can be easily obtained. Analysis results show that the largest exergy loss occurs in an exothermic reformer, accounting 60.4 percent of the total exergy loss. The exergy cost distribution diagram indicates that DMC has the highest exergy cost, followed by DME and methanol, and it is economically favorable to use the exhaust gas from the chemical synthesis block for power generation.

Process design and downstream optimization of the direct synthesis route for cleaner production of dimethyl ether from biogas

Process Simulation and Environmental Aspects of Dimethyl Ether Production from Digestate-Derived Syngas

Process Simulation of Single-Step Dimethyl Ether Production Via Biomass Gasification.

An Integrated Biomass-Derived Syngas/dimethyl Ether Process

Thermally self-sufficient process for single-step coproduction of methanol and dimethyl ether by CO 2 hydrogenation

Gasoline Synthesis from Biomass-Derived Syngas Comparing Different Methanol and Dimethyl Ether Pathways by Process Simulation, Based on the Bioliq Process

A dual-gas sourced integrated methanol/DME/DMC catalysis approach to polygeneration energy systems design and an exergoeconomic analysis

Experimental study for dimethyl ether production from biomass gasification and simulation on dimethyl ether production

Exergy analysis of dimethyl ether synthesis via biomass gasification

DESIGN AND OPERATION ANALYSIS ON 100-TON SCALE DIRECT SYNTHESIS OF DME FROM BIOMASS SYNTHESIS GAS

Co-Production of Dimethyl Carbonate, Dimethoxymethane and Dimethyl Ether from Methanol: Process Design and Exergy Analysis

Synthetic fuels and chemicals production from biomass synthesis gas

Integrated Energy-Exergy-Based Evaluation and Optimization of A Bio-Dimethyl Ether Production System Via Entrained Flow Gasification

Prospect of Direct Dimethyl Ether Production from CO2: Reactor Design Development

Process Simulation of Dimethyl Ether Synthesis Via Methanol Vapor Phase Dehydration

Techno-economic assessment of renewable dimethyl ether production pathways from hydrogen and carbon dioxide in the context of power-to-X

Modeling and Simulation of Production Process on Dimethyl Ether Synthesized from Coal-based Syngas by One-step Method

Process Simulation and Optimization of One-Step Synthesis of Dimethyl Ether from Syngas

Process Design, Economic Optimization, and Environmental Assessment for the Production of Glycerol Carbonate Via Reactive Distillation Combined with Pervaporation

Conceptual Process Design and Technoeconomic Analysis of an e-Methanol Plant with Direct Air-Captured CO 2 and Electrolytic H 2

Scale study of direct synthesis of dimethyl ether from biomass synthesis gas.