Abstract:Aiming at the high temperature corrosion problem of the water wall of a 350 MW low nitrogen boiler in a power plant, the simulation study was carried out to adjust the air distribution and increasing near-wall air. The relationship between the concentration of reducing gases CO, H 2 S and NO x in the furnace was simulated when the burn-out air rate was 38%, 33% and 27% respectively, and the effect of increasing the wall air on the concentration of reducing gases near the water wall was simulated. The results show that the burn-out air rate is reduced from 38% to 33%, which can reduce the concentration of reducing gases CO and H 2 S in the furnace by 20% without significantly increasing the amount of NO x , and slow down the high-temperature corrosion of the water wall. Reducing the burn-out air rate from 38% to 27% can increase the oxygen concentration in the main combustion zone, reduce the production of CO and H 2 S, and slow down the high-temperature corrosion of the water wall, but the NO x concentration will increase significantly. The high-temperature corrosion area in the furnace is mainly located between the UAP nozzle of the compact burnout air and the SOFA3 nozzle of the intermediate burnout air. The near-wall air can be added on both sides of the UAP nozzle of the compact burnout air. The simulation results show that the concentration of CO and H 2 S near the water wall can be reduced by increasing the near-wall wind with the same rotation direction as the main flow, and there is the small effect on the flow field. Due to the high concentration of CO near the water wall, the flow of near-wall air on both sides is larger, which has better effect on reducing CO near the water wall. The coverage area of near-wall air on both sides is larger for high-temperature corrosion area, while the concentration of H 2 S near the water wall is lower. There is no obvious difference between the single-side near-wall air and the double-side near-wall air in reducing the H 2 S of the water wall, but the double-side near-wall air will disturb the distribution of the flow field, which is not conducive to pulverized coal combustion.

A Study of Thermal Analysis Kinetics for High Temperature Corrosion of Water Wall Tube 20g at Different Density SO2

Application of Multi-Tangential Firing Technology to Settling the High Temperature Corrosion of Water Wall Tube of Boiler

Review on High Temperature Corrosion of Flue Gas from MSW Incineration

Revealing the Effect of O2, SO2 and H2O in Supercritical CO2 on the Corrosion Behavior of 316L Steel at Elevated Temperature

High-temperature corrosion of water-wall tubes in oxy-combustion atmosphere

Water Wall Tubes’ High Temperature Corrosion Root Cause Investigation: A 300 MW Level Boiler Case

Analysis and Solution of High-temperature Corrosion for a 1000 MW Ultra-supercritical Boiler

Numerical investigation of boiler waterwall corrosion by integrated tube temperature prediction and sulfur evolution model

DYNAMICS STUDY ON CORROSION TEST IN GAS-PHASE HC1 FOR SUPERHEATERS OF BIOMASS BOILERS

Experimental Investigation of Corrosion Associated with Gaseous HCl in the Superheaters in a Biomass Boiler

Study of Corrosion Kinetic Measurement and Morphology Observation of Superheater Tube 12cr1mov Alloy in Simulated MSWI Flue Gas Containing Varied HCl or SO2 Concentrations

Investigation on High-temperature Corrosion of Superheaters in Biomass Boiler

Experimental study on high temperature gaseous hydrogen fluoride corrosion of boiler water-cooled wall pipes

Failure Analysis on Abnormal Corrosion of Economizer Tubes in a Waste Heat Boiler

The Effect of SO2:HCl in Mixed Gas and Deposit Corrosion of Waste-to-Energy Boilers

Corrosion Behavior of TP316L of Superheater in Biomass Boiler with Simulated Atmosphere and Deposit

CORROSION PROPERTIES OF TP316L STEEL UNDER GASEOUS-PHASE CONDITION IN SUPERHEATER AREA OF BIOMASS-BURNING BOILERS

Analysing the Cause of High Temperature Corrosion in the Superheaters of Power Plant Systems

Effect of burnout air rate and wall air on high temperature corrosion of water wall of 350 MW tangentially fired boiler

The Transformation Mechanism of H<sub>2</sub>S beside the Water Wall under Reducing Condition

Corrosive damage analysis and characterization of boiler tubes in a secondary superheater