Abstract:This article studies the switching performance of vertical GaN power FinFETs and proposes new interfin designs to improve it. The interfin region has been found to be an important limiting factor for FinFET switching performance. The time taken to (dis)charge the dielectric parasitic capacitances and drift layer in the interfin regions severely limits the device turn-(on)off speed. Three new interfin designs are proposed, based on reduced fin-to-fin spacing, oxide full-filling (FF), and split-gate (SG) structures. The 1.2-kV, 80-mΩ vertical GaN FinFETs with these designs were evaluated by a well-calibrated device-circuit mixed-mode technology computer-aided design (TCAD) simulation. Both the reduced-fin-spacing structure and the oxide FF reduce the dielectric parasitic capacitances, but only lead to small reduction (less than 10%) in switching losses. Much better improvement is obtained with the SG structure, which removes the gate metal in the interfin region and exposes the drift layer to the field lines from the source metal. During the turn-(on)off of the transistor with a SG structure, the drift layer underneath the interfin gap region is (dis)charged by a combination of the drain-to-source and gate currents, leading to shorter switching times and lower switching losses. By utilizing the SG structure, simulations predict a 58% improvement in the switching figure-of-merit and 38% lower switching losses in 1.2-kV vertical gallium nitride (GaN) power FinFETs. These results provide key understanding and design guidelines for power FinFETs. Finally, an 800-V buck converter using a 1.2-kV GaN FinFET half-bridge module is simulated, showing excellent efficiency when operating at a multi-MHz frequency and revealing the requirement for device thermal management. This highlights the great potential of vertical GaN power FinFETs for future high-frequency medium-voltage power applications.

Vertical GaN Power Transistor with Embedded Fin-shaped Diode for High Performance Power Conversion

Low Reverse Conduction Loss $\beta $-Ga$_{\text{2}}$O$_{\text{3}}$ Vertical FinFET With an Integrated Fin Diode

Improvement of reverse conduction characteristic and single event effect for a novel vertical GaN field effect transistor with an integrated MOS-channel diode

Reverse-Conducting Normally-OFF Double-Channel AlGaN/GaN Power Transistor with Interdigital Built-In Schottky Barrier Diode

Ga$_{\text{2}}$O$_{\text{3}}$ Vertical FinFET With Integrated Schottky Barrier Diode for Low-Loss Conduction

Simulation Study of a Power MOSFET with Built-in Channel Diode for Enhanced Reverse Recovery Performance

<i>p</i>-GaN Gate Power Transistor With Distributed Built-in Schottky Barrier Diode for Low-loss Reverse Conduction

Reverse Conducting Double Gate Lateral Insulated Gate Bipolar Transistor in Soi Based Technology

High performance SiC trench-type MOSFET with an integrated MOS-channel diode

A Novel 6500 V SiC Trench MOSFET with Integrated Unipolar Diode for Improved Third Quadrant and Switching Characteristics

An ultralow loss 4H-SiC double trenches MOSFET with integrated heterojunction diodes and split gate

An Interdigitated Gan Mis-Hemt/Sbd Normally-Off Power Switching Device With Low On-Resistance And Low Reverse Conduction Loss

Proposal of a novel GaN/SiC hybrid FET (HyFET) with enhanced performance for high-voltage switching applications

Switching Performance Analysis of Vertical GaN FinFETs: Impact of Interfin Designs

Fully Vertical GaN-on-SiC p-i-n Diodes With BFOM of 2.89 GW/cm2

Numerical Study of Novel GaN HEMTs With Integrated SBDs for Ultrahigh Reverse Conduction Capability

700-V <i>p</i>-GaN Gate HEMT with Low-Voltage Third Quadrant Operation Using Area-Efficient Built-in Diode

A Novel Asymmetric Trench SiC Metal–Oxide–Semiconductor Field-Effect Transistor with a Poly-Si/SiC Heterojunction Diode for Optimizing Reverse Conduction Performance

Silicon Carbide Split-Gate MOSFET with Merged Schottky Barrier Diode and Reduced Switching Loss

Low Switching Loss Split-Gate 4H-SiC MOSFET With Integrated Heterojunction Diode

Integrated Junction Barrier Schottky Diode and MOS-Channel Diode in SiC Planar MOSFETs for Optimization of Reverse Performances