Abstract:Al2O3, as one of the gate dielectric materials for thin film transistors (TFTs), has been extensively investigated because of its large bandgap, high breakdown field, and good thermal stability. However, the further development of Al2O3 thin films is limited by the presence of defects such as oxygen vacancies, self-interstitial atoms, or impurity elements. To overcome this obstacle, we have developed a novel method for fabricating Al2O3 thin films by using the atomic layer deposition (ALD) technique. This method replaces the conventional Trimethylaluminium (TMA)/H2O cycles with TMA/TMA/H2O/H2O cycles (referred to as ‘double cycles’), to deposit the Al2O3. The 5-nm ultrathin Al2O3 film showed a high areal capacitance of 660 nF/cm2 at 20 Hz, and a relatively low current density of 10−8 A/cm2 at 1 MV/cm. InGaZnO (IGZO) TFTs with ultrathin Al2O3 gate dielectric grown by double cycles exhibited outstanding performances, such as a near theoretical limit subthreshold swing (SS) of 70 mV/decade, a higher on/off current ratio $(I_{\mathrm{ on}} / I_{\mathrm{ off}}$ ) of 106, an increased field-effect mobility ( $\mu $ ) of 6.5 cm2/Vs, a lower threshold voltage $(V_{\mathrm{ th}})$ of 0.2 V, and a low operating voltage of 3 V. These results are superior to the IGZO TFTs with Al2O3 dielectrics deposited using the single TMA/H2O cycle. Therefore, the implementation of ‘double cycles’ in the fabrication of dielectrics through ALD demonstrates considerable potential for future application in low-power electronic devices.

A novel steep slope hybrid InGaZnO TFT with negative DIBL improvement based on the Ag/HfO2 threshold switching device

High-Performance Amorphous InGaZnO Thin-Film Transistor Gated by HfAlOₓ Dielectric with Ultralow Subthreshold Swing

High-performance IGZO-based TFTs with Stacked Al<sub>2</sub>O<sub>3</sub>/HfO<sub>2</sub> Dielectrics

Effect of HfO2-Based Multi-Dielectrics on Electrical Properties of Amorphous In-Ga-Zn-O Thin Film Transistors

Fabrication and Properties of InGaZnO Thin-Film Transistors Based on a Sol–Gel Method with Different Electrode Patterns

Steep Subthreshold Swing and Enhanced Illumination Stability InGaZnO Thin-Film Transistor by Plasma Oxidation on Silicon Nitride Gate Dielectric

Sol-gel Indium-Zinc-tin-oxide Thin Film Transistor Pixel Array with Superior Stabilityunder Negative Bias Illumination Stress

High-Performance Amorphous InGaZnO Thin Film Transistor With High-k Van Der Waals Molecular Dielectric

High-Performance Indium-Gallium-Zinc-Oxide Thin-Film Transistors with Stacked Al<sub>2</sub>O<sub>3</sub>/HfO<sub>2</sub> Dielectrics

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al₂O₃ Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

High Performance and Hysteresis-Free a-IGZO Thin Film Transistors Based on Spin-coated Hafnium Oxide Gate Dielectrics

Amorphous InGaZnO Thin Film Transistors with Wet-Etched Ag Electrodes

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al2O3 Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

P‐1.1: Co‐sputtering‐deposited Hf‐doped ITO Thin Films for Thin Film Transistors Application

Dual Active Layer Mg-Doped InZnO Thin-Film Transistors with Ultra-Low Indium Doping

Enhanced Bias Stress Stability of A-Ingazno Thin Film Transistors by Inserting an Ultra-Thin Interfacial InGaZnO:N Layer

Amorphous indium–gallium–zinc–oxide thin-film transistors using organic–inorganic hybrid films deposited by low-temperature plasma-enhanced chemical vapor deposition for all dielectric layers

Improved mobility and bias stability of Hf-doped IGZO/IZO/Hf-doped IGZO thin-film transistor

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al<sub>2</sub>O<sub>3</sub> Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

Negative-U Defect Passivation in Oxide-Semiconductor by Channel Defect Self-Compensation Effect to Achieve Low Bias Stress VTH Instability of Low-Thermal Budget IGZO TFT and FeFETs

Ultra-thin top-gate insulator of atomic-layer-deposited HfO x for amorphous InGaZnO thin-film transistors