Abstract:Nanocrystalline soft magnetic materials with low coercivity, high saturation magnetization and high permeability are commonly used as cores in transformers and generators in stress and field sensors. The influence of factors connected with corrosion is almost impossible to eliminate. In the present work, a comparative study of the electrochemical behavior of Fe78Si13B9 and Fe73.5Si13.5B9Nb3Cu1 amorphous and nanocrystallized alloys, tested in 0.5M NaCl solution, has been performed by linear polarization and electrochemical impedance spectroscopy methods. Changes of magnetic properties including coercivity, induction and magnetic retentivity were analyzed. These properties were investigated as a function of the structure of primary amorphous ribbons and as a function of corrosion environment type, in which longitudinally and transversely cut ribbon specimens were exposed for 15 days. The best magnetic properties were found for the Fe78Si9B13 ribbon after a structural relaxation at a temperature of 350°C for an hour and for the Fe73.5Si13.5B9Nb3Cu1 ribbon after a primary crystallization at a temperature of 550°C for an hour. Corrosion did not cause the direct degradation of the magnetic properties of the Fe78Si9B13 and Fe73.5Si13.5B9Nb3Cu1 alloys. The corrosion processes occurring on the surface of the Fe73.5Si13.5B9Nb3Cu1 alloy ribbon with the amorphous structures improve induction Bs. Most probably it is connected with the decrease of undesirable stresses blocking a motion of magnetic domain walls on the ribbon surface. Changes of corrosion mechanism depending on structure and applied solution were analyzed. The electrochemical impedance experiment were performed at open circuit potential for amorphous and nanocrystalline specimens. Two electrochemical corrosion mechanisms of Fe73.5Si13.5B9Nb3Cu1 alloy in 0.5M NaCl solution were found. Charge transfer control mechanism is typical for amorphous (as received) alloys. Mixed mechanism-mass transport and charge transfer controlled was observed for nanocrystalline Fe73.5Si13.5B9Nb3Cu1 alloy.

Corrosion Resistance and Electrochemical Behaviour of Amorphous Ni84.9Cr7.4Si4.2Fe3.5 Alloy in Alkaline and Acidic Solutions

Corrosion behaviors of amorphous and nanocrystalline Fe-based alloys in NaCl solution

The Comparision of Corrosion Resistance of Amorphous and Nanocrystalline Fe-based Alloys in NaOH Solutions

Influence of Cr on Microstructure and Electrochemical Properties of FeNiMnCuCrx High-entropy Alloy

Corrosion Resistance of Amorphous and Crystalline Pd40ni40p20 Alloys in Aqueous Solutions

The Influence of the Composition of Amorphous Alloys on Their Corrosion Resistance in Aggressive Environments of Different Nature

Crystallization behavior and corrosion resistance of Al86Ni10Zr4 amorphous alloy under different annealing treatment conditions

Effect of crystallization on corrosion behavior of Fe40Ni38B18Mo4 amorphous alloy in 3.5% sodium chloride solution

Microstructure and Corrosion Property of Equiatomic AlNiZrCuY High Entropy Amorphous Composite Material

Corrosion of amorphous Fe73.5Si13.5B 9Nb3Cu1 alloys on the synergistic effect of chloride and hydroxyl ions

Electrochemical Behavior of Cobalt-Based Nanostructured Amorphous Alloys in Alkaline Solution

Fe61.5Cr17.5Ni13Al8 High-Entropy Alloy: A Study of Corrosion Behavior

Electrochemical Corrosion Resistance of the Amorphous and Crystalline Pd‐based Alloys in Simulated Seawater

Corrosion and passive behaviors of the Co-Cr-Fe-Ni-Nb eutectic high-entropy alloys in different electrolyte solutions

Corrosion of Amorphous Fe<sub>73.5</sub>Si<sub>13.5</sub>B<sub>9</sub>Nb<sub>3</sub>Cu<sub>1</sub> Alloys on the Synergistic Effect of Chloride and Hydroxyl Ions

The corrosion behavior and film properties of Al-containing high-entropy alloys in acidic solutions

Corrosion of Amorphous Fe<sub>73.5</sub>Si<sub>13.5</sub>B<sub>9</sub>Nb<sub>3</sub>Cu<sub>1</sub> Alloys on the Synergistic Effect of Chloride and Hydroxyl Ions

Corrosion of amorphous and nanocrystalline Fe-based alloys and its influence on their magnetic behavior

Effect of Surface Microstructure on the Corrosion Resistance and Magnetic Properties of an Amorphous Cobalt-Based Co–Si–Fe–Cr–Al Alloy

Effect of surface microstructure for corrosion resistance and magnetic properties of an amorphous cobalt-based Co-Si-Fe-Cr-Al ALLOY

Corrosion Behavior of Cold-Rolled and Solution-Treated Fe36Mn20Ni20Cr16Al5Si3 HEA in Different Acidic Solutions

Corrosion Resistance and Electrochemical Behaviour of Amorphous Ni84.9Cr7.4Si4.2Fe3.5 Alloy in Alkaline and Acidic Solutions

Corrosion behaviors of amorphous and nanocrystalline Fe-based alloys in NaCl solution

The Comparision of Corrosion Resistance of Amorphous and Nanocrystalline Fe-based Alloys in NaOH Solutions

Influence of Cr on Microstructure and Electrochemical Properties of FeNiMnCuCrx High-entropy Alloy

Corrosion Resistance of Amorphous and Crystalline Pd40ni40p20 Alloys in Aqueous Solutions

The Influence of the Composition of Amorphous Alloys on Their Corrosion Resistance in Aggressive Environments of Different Nature

Crystallization behavior and corrosion resistance of Al86Ni10Zr4 amorphous alloy under different annealing treatment conditions

Effect of crystallization on corrosion behavior of Fe40Ni38B18Mo4 amorphous alloy in 3.5% sodium chloride solution

Microstructure and Corrosion Property of Equiatomic AlNiZrCuY High Entropy Amorphous Composite Material

Corrosion of amorphous Fe73.5Si13.5B 9Nb3Cu1 alloys on the synergistic effect of chloride and hydroxyl ions

Electrochemical Behavior of Cobalt-Based Nanostructured Amorphous Alloys in Alkaline Solution

Fe61.5Cr17.5Ni13Al8 High-Entropy Alloy: A Study of Corrosion Behavior

Electrochemical Corrosion Resistance of the Amorphous and Crystalline Pd‐based Alloys in Simulated Seawater

Corrosion and passive behaviors of the Co-Cr-Fe-Ni-Nb eutectic high-entropy alloys in different electrolyte solutions

Corrosion of Amorphous Fe&lt;sub&gt;73.5&lt;/sub&gt;Si&lt;sub&gt;13.5&lt;/sub&gt;B&lt;sub&gt;9&lt;/sub&gt;Nb&lt;sub&gt;3&lt;/sub&gt;Cu&lt;sub&gt;1&lt;/sub&gt; Alloys on the Synergistic Effect of Chloride and Hydroxyl Ions

The corrosion behavior and film properties of Al-containing high-entropy alloys in acidic solutions

Corrosion of Amorphous Fe<sub>73.5</sub>Si<sub>13.5</sub>B<sub>9</sub>Nb<sub>3</sub>Cu<sub>1</sub> Alloys on the Synergistic Effect of Chloride and Hydroxyl Ions

Corrosion of amorphous and nanocrystalline Fe-based alloys and its influence on their magnetic behavior

Effect of Surface Microstructure on the Corrosion Resistance and Magnetic Properties of an Amorphous Cobalt-Based Co–Si–Fe–Cr–Al Alloy

Effect of surface microstructure for corrosion resistance and magnetic properties of an amorphous cobalt-based Co-Si-Fe-Cr-Al ALLOY

Corrosion Behavior of Cold-Rolled and Solution-Treated Fe36Mn20Ni20Cr16Al5Si3 HEA in Different Acidic Solutions

Corrosion of Amorphous Fe<sub>73.5</sub>Si<sub>13.5</sub>B<sub>9</sub>Nb<sub>3</sub>Cu<sub>1</sub> Alloys on the Synergistic Effect of Chloride and Hydroxyl Ions