Abstract:The removal of low concentration ammonia-nitrogen in industrial wastewater is necessary before discharged into the environment. In this study, vacuum plate membrane distillation (VPMD) technology was utilized and operating parameters such as pH, feed temperature, vacuum degree, feed flow and time were investigated. Based on the experimental data, the heat and mass transfer mechanism and mathematic model were studied. The experimental results show that low solution pH was significantly beneficial to ammonia-nitrogen removal but permeate flux was nearly changeless. At pH = 4, a removal rate up to 93.33% was achieved. Ammonia-nitrogen mainly exists with NH4+ ions in acidic solution, so only water molecules pass through the membrane to acquire the water product in the permeate side. Increasing the temperature of the solution was disadvantageous to the ammonia-nitrogen removal due to membrane pores expanding and the mass transfer coefficient of NH3 molecules increasing; therefore a low temperature was chosen if possible. Because vapor pressure of the feed solution increases exponentially with temperature and results in membrane surface pressure difference increases, therefore increasing the temperature enhances the permeate flux. Raising the vacuum degree enhanced ammonia removal rate and permeate flux obviously, a vacuum degree of 0.09 MPa was chosen for the experiment. The effect of feed flow rate on ammonia-nitrogen removal instead of permeate flux is weak, the reason is that the boundary layer wears thin when the feed flow rate is increased, which is conducive to permeate flux increasing. In a two-parameter model of Knudsen diffusion, Poiseuille flow was chosen to demonstrate the heat and mass transfers in the process of VPMD in the study. Based on the experimental values of permeate flux, two parameters CK and CP in the model were calculated using a nonlinear fitting method software, which indicated that the Knudsen diffusion model more than the Poiseuille flow model was suitable. The maximum values of the relative average deviation (RAD) and root mean square difference (RMSD) of experimental and calculated values with model equations of the permeate flux at the different temperature, vacuum degree and feed flow rate were no more than 8.7% and 3.20 kg · (m2 · h)-1, respectively.

Ammonia Removal from Aqueous Solutions by Vacuum Membrane Distillation——Study on Mass Transfer Coefficient

Ammonia Removal from Aqueous Solutions by Vacuum Membrane Distillation——Study on the Influences of Technological Conditions

CO2 Removal from Air by Hollow-fiber Membrane-based Absorption System

Experimental and numerical study on effects of airflow and aqueous ammonium solution temperature on ammonia mass transfer coefficient

Study on treatment of wastewater with low concentration of ammonia-nitrogen by vacuum plate membrane distillation technology

Experimental Study of CO2 Regeneration from Ammonia Rich Solution by Membrane Vacuum Regeneration

Mass Transfer Coefficients for CO2 Absorption into Aqueous Ammonia Solution Using a Packed Column

Study on efficient removal technology of ammonia nitrogen by membrane separation

Volumetric Overall Mass Transfer Coefficients of CO_2 Absorption Into Aqueous Ammonia of Fine Spray

Study on Temperature and Pressure Distribution and Flux of Vacuum Membrane Distillation

De-ammonification using direct contact membrane distillation – An experimental and simulation study

CFD Model Development and Experimental Measurements for Ammonia–Water Separation Using a Vacuum Membrane Distillation Module

ExperimentaI study on the removaI of ammonia nitrogen from aqueous soIution with the cross-fIow hoIIow fiber membrane contactor

Experimental and Simulated Study on Mass and Heat Transfer of Falling Film Evaporator for Ammonia-Containing Wastewater

Numerical Study on Absorption of Carbon Dioxide and Mass Transfer Performance in Hollow Fiber Membrane Contactor

A venturi reactor with an excellent mass transfer performance for carbon dioxide capture

The effect of ammonia initial concentration in membrane distillation process for high ammonia concentration wastewater treatment

A Novel Method to Recover Ammonia Loss in Ammonia‐based CO 2 Capture System: Ammonia Regeneration by Vacuum Membrane Distillation

Mass Transfer Study of Ammonia-water Falling-film Absorption in Vertical Tube

Mass transfer in hollow fiber vacuum membrane distillation process based on membrane structure

Review of Ammonia Recovery and Removal from Wastewater Using Hydrophobic Membrane Distillation and Membrane Contactor