Abstract:The removal of low concentration ammonia-nitrogen in industrial wastewater is necessary before discharged into the environment. In this study, vacuum plate membrane distillation (VPMD) technology was utilized and operating parameters such as pH, feed temperature, vacuum degree, feed flow and time were investigated. Based on the experimental data, the heat and mass transfer mechanism and mathematic model were studied. The experimental results show that low solution pH was significantly beneficial to ammonia-nitrogen removal but permeate flux was nearly changeless. At pH = 4, a removal rate up to 93.33% was achieved. Ammonia-nitrogen mainly exists with NH4+ ions in acidic solution, so only water molecules pass through the membrane to acquire the water product in the permeate side. Increasing the temperature of the solution was disadvantageous to the ammonia-nitrogen removal due to membrane pores expanding and the mass transfer coefficient of NH3 molecules increasing; therefore a low temperature was chosen if possible. Because vapor pressure of the feed solution increases exponentially with temperature and results in membrane surface pressure difference increases, therefore increasing the temperature enhances the permeate flux. Raising the vacuum degree enhanced ammonia removal rate and permeate flux obviously, a vacuum degree of 0.09 MPa was chosen for the experiment. The effect of feed flow rate on ammonia-nitrogen removal instead of permeate flux is weak, the reason is that the boundary layer wears thin when the feed flow rate is increased, which is conducive to permeate flux increasing. In a two-parameter model of Knudsen diffusion, Poiseuille flow was chosen to demonstrate the heat and mass transfers in the process of VPMD in the study. Based on the experimental values of permeate flux, two parameters CK and CP in the model were calculated using a nonlinear fitting method software, which indicated that the Knudsen diffusion model more than the Poiseuille flow model was suitable. The maximum values of the relative average deviation (RAD) and root mean square difference (RMSD) of experimental and calculated values with model equations of the permeate flux at the different temperature, vacuum degree and feed flow rate were no more than 8.7% and 3.20 kg · (m2 · h)-1, respectively.

Study on efficient removal technology of ammonia nitrogen by membrane separation

Removal Efficiency of Combined Treatment Process on Raw Water with High Ammonia Nitrogen and High Organic Pollutants

Study on Removal of Organic Matters in Water by PVA Modified PA-TFC Nanofiltration Membrane

Efficient ammonia-nitrogen removal and recovery from wastewater via the continuous flat-sheet gas-permeable membranes reactor pretreatment

Study on treatment of wastewater with low concentration of ammonia-nitrogen by vacuum plate membrane distillation technology

Research On The Application Of Membrane Absorption For The High Concentration Ammonia Wastewater Treatment

[Operation Performance of Membrane Nitrification Bioreactor for Ammonia-Containing Wastewater].

Removal of Cyanide and Ammonia Nitrogen from Acrylonitrile Wastewater by Membrane Absorption Process

Deep Purification of Low-Strength Ammonium-Containing Wastewater with ANRE Process

Recent developments in membrane technology for the elimination of ammonia from wastewater: A review

Ammonia harvesting via membrane gas extraction at moderately alkaline pH: A step toward net-profitable nitrogen recovery from domestic wastewater

Nafion-PTFE hollow fiber composite membranes for ammonia removal and recovery using an aqueous-organic membrane contactor

Application of gas cyclone–liquid jet absorption separator for purification of tail gas containing ammonia

Contactless membrane distillation for effective ammonia recovery from waste sludge: A new configuration and mass transfer mechanism

Study on Carbon and Nitrogen Removal by Membrane Aeration Bioreactor

Ammonia enrichment and recovery via ion exchange from municipal wastewater after filtered by ultrafiltration membrane

Application of physicochemical techniques to the removal of ammonia nitrogen from water: a systematic review

Ammonia recovery from landfill leachate using gas-permeable membranes: Comparison of membrane fibers and expanded membrane tubes in both in-situ and shell-tube configurations

A Novel Method to Recover Ammonia Loss in Ammonia‐based CO 2 Capture System: Ammonia Regeneration by Vacuum Membrane Distillation

Experimental Study on Treatment of Low Concentration Ammonia Wastewater by Natural Zeolite

Study on Ammonia-Nitrogen Removal in Wastewater Using Electrochemical Method