Abstract:Selective removal and resource recovery of ammonium nitrogen (NH4+–N) from high-strength ammonium waste streams is of practical importance for biological wastewater treatment and environmental protection. In this study, we demonstrate the simultaneous removal and reclamation of ammonium from synthetic digested sludge centrate via a novel osmosis-distillation hybrid membrane (ODHM) process. Using NaHCO3 as the draw solute, ammonium diffuses from the synthetic centrate to the draw solution by utilizing the bidirectional cation transport nature of the thin film composite (TFC) membrane. Then, NH4+ is converted to gaseous NH3 at 60 °C and recovered by a sweeping gas membrane distillation (SGMD) process. Herein, the bidirectional transport of monovalent cations in the osmotic process, selectivity of TFC membranes for different cations, and recovery of the draw solution following the extraction of ammonia through the SGMD process were systematically investigated. The removal of NH4+–N from the synthetic centrate achieved 21.34% during a 6-h continuous operation of the ODHM system, with ammonium fluxes through the TFC and SGMD membranes at 1.39 and 0.57 mol m–2 h–1, respectively. A secondary interfacial polymerization was proposed to further enhance ammonium transport through the TFC membrane. Results reported here highlight the potential of the ODHM process for the selective removal and reclamation of ammonium from ammonium-rich waste streams.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acs.est.0c01496?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acs.est.0c01496</a>.S1, Experimental protocol for selective removal and reclamation of ammonium nitrogen; S2, silver binding method; S3, supplemental description of analytical methods; S4, bidirectional transport of ions through the TFC membrane; Figure S1, schematic diagram of the lab-scale ODHM system; Figure S2, effect of NaHCO3 background on the accuracy of NH4+–N measurement; Figure S3, influence of NaHCO3 background concentration on measurement accuracy during ICP-OES analysis of K+, Ca2+, and Mg2+; Figure S4, fluxes of reverse and forward transported ions in the osmotic process; Figure S5, specific salt flux (SFF) for cations of the TFC membrane; Figure S6, conductivity, pH, water flux, and the ammonium concentration in centrate as a function of experimental time during the treatment of synthetic centrate by ODHM process; Figure S7, SSF for NH4+ of the TFC pristine and modified membranes; Table S1, brief summary of biological treatments, chemical/physical extractions, and membrane processes on ammonium removal; Table S2, composition and pH of the feed and draw solutions for the experiments in <a class="internalNav" href="#fig1">Figure </a><a class="internalNav" href="#fig1">1</a>B; and Table S3, composition of the feed and draw solutions for the experiments in <a class="internalNav" href="#fig1">Figure </a><a class="internalNav" href="#fig1">1</a>E (<a class="ext-link" href="/doi/suppl/10.1021/acs.est.0c01496/suppl_file/es0c01496_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

Research On The Application Of Membrane Absorption For The High Concentration Ammonia Wastewater Treatment

Effect of the Rapid Increase of Salinity on Anoxic-Oxic Biofilm Reactor for Treatment of High-Salt and High-Ammonia-nitrogen Wastewater.

Study on efficient removal technology of ammonia nitrogen by membrane separation

Contactless membrane distillation for effective ammonia recovery from waste sludge: A new configuration and mass transfer mechanism

A Novel Method to Recover Ammonia Loss in Ammonia‐based CO 2 Capture System: Ammonia Regeneration by Vacuum Membrane Distillation

Ammonia enrichment and recovery via ion exchange from municipal wastewater after filtered by ultrafiltration membrane

Removal of Cyanide and Ammonia Nitrogen from Acrylonitrile Wastewater by Membrane Absorption Process

Utilization of Bidirectional Cation Transport in a Thin Film Composite Membrane: Selective Removal and Reclamation of Ammonium from Synthetic Digested Sludge Centrate via an Osmosis–Distillation Hybrid Membrane Process

Deep Purification of Low-Strength Ammonium-Containing Wastewater with ANRE Process

A Feasibility Study of Ammonia Recovery from Coking Wastewater by Coupled Operation of a Membrane Contactor and Membrane Distillation

The design of multi-stage open-loop hollow fiber membrane contactor and its application in ammonia capture from hydrolyzed human urine

Ammonia recovery from simulated anaerobic digestate using a two‐stage direct contact membrane distillation process

Ammonia reduction using zeolite followed by a sequencing batch reactor to treat plant effluents

Nafion-PTFE hollow fiber composite membranes for ammonia removal and recovery using an aqueous-organic membrane contactor

Performance of thin film composite membranes for ammonium removal and reuse of ammonium-enriched solution for plant growth

Low chemical consumption of wastewater ammonium nitrogen recovery through Donnan dialysis-membrane stripping process

Efficient ammonia-nitrogen removal and recovery from wastewater via the continuous flat-sheet gas-permeable membranes reactor pretreatment

A Study on the PP Hollow Fiber Membrane Contactor and Its Performance for Removing Ammonia from Wastewater or Mixed Gas: II. Ammonia Removal from Mixed Gas

Ammonia harvesting via membrane gas extraction at moderately alkaline pH: A step toward net-profitable nitrogen recovery from domestic wastewater

Treatment of Ammonia Nitrogen in Landfill Leachate by Combined Membranes-Anionic Surfactant Method

Study on treatment of wastewater with low concentration of ammonia-nitrogen by vacuum plate membrane distillation technology