Abstract:Selective removal and resource recovery of ammonium nitrogen (NH4+–N) from high-strength ammonium waste streams is of practical importance for biological wastewater treatment and environmental protection. In this study, we demonstrate the simultaneous removal and reclamation of ammonium from synthetic digested sludge centrate via a novel osmosis-distillation hybrid membrane (ODHM) process. Using NaHCO3 as the draw solute, ammonium diffuses from the synthetic centrate to the draw solution by utilizing the bidirectional cation transport nature of the thin film composite (TFC) membrane. Then, NH4+ is converted to gaseous NH3 at 60 °C and recovered by a sweeping gas membrane distillation (SGMD) process. Herein, the bidirectional transport of monovalent cations in the osmotic process, selectivity of TFC membranes for different cations, and recovery of the draw solution following the extraction of ammonia through the SGMD process were systematically investigated. The removal of NH4+–N from the synthetic centrate achieved 21.34% during a 6-h continuous operation of the ODHM system, with ammonium fluxes through the TFC and SGMD membranes at 1.39 and 0.57 mol m–2 h–1, respectively. A secondary interfacial polymerization was proposed to further enhance ammonium transport through the TFC membrane. Results reported here highlight the potential of the ODHM process for the selective removal and reclamation of ammonium from ammonium-rich waste streams.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acs.est.0c01496?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acs.est.0c01496</a>.S1, Experimental protocol for selective removal and reclamation of ammonium nitrogen; S2, silver binding method; S3, supplemental description of analytical methods; S4, bidirectional transport of ions through the TFC membrane; Figure S1, schematic diagram of the lab-scale ODHM system; Figure S2, effect of NaHCO3 background on the accuracy of NH4+–N measurement; Figure S3, influence of NaHCO3 background concentration on measurement accuracy during ICP-OES analysis of K+, Ca2+, and Mg2+; Figure S4, fluxes of reverse and forward transported ions in the osmotic process; Figure S5, specific salt flux (SFF) for cations of the TFC membrane; Figure S6, conductivity, pH, water flux, and the ammonium concentration in centrate as a function of experimental time during the treatment of synthetic centrate by ODHM process; Figure S7, SSF for NH4+ of the TFC pristine and modified membranes; Table S1, brief summary of biological treatments, chemical/physical extractions, and membrane processes on ammonium removal; Table S2, composition and pH of the feed and draw solutions for the experiments in <a class="internalNav" href="#fig1">Figure </a><a class="internalNav" href="#fig1">1</a>B; and Table S3, composition of the feed and draw solutions for the experiments in <a class="internalNav" href="#fig1">Figure </a><a class="internalNav" href="#fig1">1</a>E (<a class="ext-link" href="/doi/suppl/10.1021/acs.est.0c01496/suppl_file/es0c01496_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

Ammonia recovery from simulated anaerobic digestate using a two‐stage direct contact membrane distillation process

Effect of Ammonia Concentration on Hythane (H2 and CH4) Production in Two-Phase Anaerobic Digestion

De-ammonification using direct contact membrane distillation – An experimental and simulation study

Combined coagulation and membrane treatment for anaerobically digested manure centrate: Contaminant residuals and membrane fouling

Contactless membrane distillation for effective ammonia recovery from waste sludge: A new configuration and mass transfer mechanism

Simultaneous ammonium and water recovery from landfill leachate using an integrated two-stage membrane distillation

Hybrid Donnan dialysis-electrodialysis for efficient ammonia recovery from anaerobic digester effluent

Low chemical consumption of wastewater ammonium nitrogen recovery through Donnan dialysis-membrane stripping process

A Feasibility Study of Ammonia Recovery from Coking Wastewater by Coupled Operation of a Membrane Contactor and Membrane Distillation

A Novel Method to Recover Ammonia Loss in Ammonia‐based CO 2 Capture System: Ammonia Regeneration by Vacuum Membrane Distillation

Ammonia Removal from Municipal Wastewater Via Membrane Capacitive Deionization (MCDI) in Pilot-Scale

Utilization of Bidirectional Cation Transport in a Thin Film Composite Membrane: Selective Removal and Reclamation of Ammonium from Synthetic Digested Sludge Centrate via an Osmosis–Distillation Hybrid Membrane Process

Water Reduction and Nutrient Reconcentration of Hydrolyzed Urine Via Direct-Contact Membrane Distillation: Ammonia Loss and Its Control

Research On The Application Of Membrane Absorption For The High Concentration Ammonia Wastewater Treatment

Nafion-PTFE hollow fiber composite membranes for ammonia removal and recovery using an aqueous-organic membrane contactor

Sustainable ammonia resource recovery from landfill leachate by solar-driven modified direct contact membrane distillation

A stacked transmembrane electro-chemisorption system connected by hydrophobic gas permeable membranes for on-site utilization of authigenic acid and base to enhance ammonia recovery from wastewater

Integrating Chemical Precipitation and Membrane Separation for Phosphorus and Ammonia Recovery from Anaerobic Digestate

Ammonia harvesting via membrane gas extraction at moderately alkaline pH: A step toward net-profitable nitrogen recovery from domestic wastewater

Recovery of ammonia nitrogen from simulated reject water by bipolar membrane electrodialysis

A novel electrocoagulation-membrane stripping hybrid system for simultaneous ammonia recovery and contaminant removal