Abstract:A new process to crystallize amorphous silicon without melting and the generation of excessive heating of nearby components is presented. We propose the addition of a molybdenum layer to improve the quality of the laser-induced crystallization over that achieved by direct irradiation of silicon alone. The advantages are that it allows the control of crystallite size by varying the applied fluence of a near-infrared femtosecond laser. It offers two fluence regimes for nanocrystallization and polycrystallization with small and large crystallite sizes, respectively. The high repetition rate of the compact femtosecond laser source enables high-quality crystallization over large areas. In this proposed method, a multilayer structure is irradiated with a single femtosecond laser pulse. The multilayer structure includes a substrate, a target amorphous Si layer coated with an additional molybdenum thin film. The Si layer is crystallized by irradiating the Mo layer at different fluence regimes. The transfer of energy from the irradiated Mo layer to the Si film causes the crystallization of amorphous Si at low temperatures (∼700 K). Numerical simulations were carried out to estimate the electron and lattice temperatures for different fluence regimes using a two-temperature model. The roles of direct phonon transport and inelastic electron scattering at the Mo-Si interface were considered in the transfer of energy from the Mo to the Si film. The simulations confirm the experimental evidence that amorphous Si was crystallized in an all-solid-state process at temperatures lower than the melting point of Si, which is consistent with the results from transmission electron microscopy (TEM) and Raman. The formation of crystallized Si with controlled crystallite size after laser treatment can lead to longer mean free paths for carriers and increased electrical conductivity.

Crystallizing amorphous silicon film by using femtosecond laser pulses

Room Temperature Crystallization of Amorphous Silicon Film by Ultrashort Femtosecond Laser Pulses

Ultra-fast laser-induced crystallization of amorphous silicon films - (LPM 2001)

Ultra-fast laser-induced recrystallization of amorphous silicon films

Femtosecond Laser-Induced Crystallization of Amorphous Silicon Thin Films under a Thin Molybdenum Layer

Molecular Dynamics Simulations of Pulsed Laser Crystallization of Amorphous Silicon Ultrathin Films

Large-Scale and Localized Laser Crystallization of Optically Thick Amorphous Silicon Films by Near-IR Femtosecond Pulses

Application of 532 nm solid nanosecond laser in crystallization of amorphous silicon thin films

Femtosecond Laser Induced Nanocone Structure and Simultaneous Crystallization of 1.6 Μm Amorphous Silicon Thin Film for Photovoltaic Application

Pulse laser crystallization of silicon carbon thin films

Molecular dynamics studies of ultrafast laser-induced phase and structural change in crystalline silicon

Phosphorous-Doped $\alpha$ -Si Film Crystallization Using Heat-Assisted Femtosecond Laser Annealing

Laser Processing and In-Situ Diagnostics for Crystallization: from Thin Films to Nanostructures

Femtosecond laser crystallization of amorphous titanium oxide thin films

Study of Femtosecond Laser Induced Periodic Structure on Amorphous Silicon Films and Crystallization Characteristics

Transient phase change in picosecond laser pulse-driven crystallization process of as-deposited amorphous thin films

Femtosecond laser induced ablation of crystalline silicon upon double beam irradiation

Analysis of the Structure of Laser Crystallized amorphous Silicon Thin Film

Mechanism of Femtosecond-Laser-induced Periodic Nanostructure Formation on Crystalline Silicon Surface Immersed in Water

Exploration in the Two-Photon Absorption Effect of Silicon Based Films

One-Step femtosecond laser irradiation of Single-Crystal Silicon: Evolution of Micro-Nano structures and damage investigation