Abstract:For improving the functionality and signal speed of electronic devices, electronic components have been miniaturized and an increasing number of elements have been packaged in the device. As a result there has been a steady rise in the amount of heat necessitated to be dissipated from the electronic device. Recently microchannel heat sinks have been emerged as a kind of high performance cooling scheme to meet the heat dissipation requirement of electronics packaging, In the present study an experimental study of subcooled flow boiling in a high-aspect-ratio, one-sided heating rectangular microchannel with gap depth of 0.52 mm and width of 5 mm was conducted with deionized water as the working fluid. In the experimental operations, the mass flux was varied from 200 to 400 kg/m2s and mposed heat flux from 3 to 20 W/cm2 while the fluid inlet emperature was regulated constantly at 90 C. The boiling curves, flow pattern and onset of nucleate boiling of subcooled flow boiling were investigated through instrumental measurements and a high speed camera. It was found that the lope of the boiling curves increased sharply once the superheat needed to initiate the onset of nucleate boiling was attained, and he slope was greater for lower mass fluxes, with lower superheat equired for boiling incipience. As for the visualization images, or relatively lower mass fluxes the bubbles generated were arger and not easy to depart from the vertical upward placed Yarrow microchannel wall, giving elongated bubbly flow and reverse backflow. The thin film evaporation mechanism dominated the entire test section due to the elongated bubbles and transient local dryout as well as rewetting occurred. Meanwhile the initiative superheat and heat flux of onset of nucleate boiling were compared with existing correlations in the literature with good agreement.

Experiment study of flow boiling heat transfer characteristics in horizontal rectangular channel

Bubble Dynamics of Water Boiling Heat Transfer in Vertical Rectangular Mini-Channel

Experimental study of two-phase parameters of subcooled boiling flow in a single-side heated rectangular channel

Experimental and Numerical Study of Flow Boiling in a Vertical Upward Narrow Rectangular Channel under Low Heat Flux

Bubble Behavior of Flow Boiling in Horizontal Rectangular Channels with Inclined Ribs

Heat Transfer Characteristics of Water During Flow Boiling in a Vertical Rectangular Mini-channel

Experimental Investigations of Two-Phase Boiling Flow in A Complicated Channel

Experimental Study on the Heat Transfer of Water Boiling Flow in Narrow Horizontal Rectangular Channels

Forced Convective Boiling Heat Transfer of Water in Vertical Rectangular Narrow Channel

Visual Experimental Study on Bubble Characteristics Near the Heating Wall in Subcooled Flow Boiling

Local Heat Transfer in Subcooled Flow Boiling in a Vertical Mini-Gap Channel

Numerical simulation of boiling behavior in vertical microchannels

Experimental Study on Local Subcooled Flow Boiling Heat Transfer in A Vertical Mini-Gap Channel

Flow boiling heat transfer characteristics and mechanism analysis of high-pressure water in parallel twin narrow rectangular channels

Experimental Study on Flow Boiling of Deionized Water in a Horizontal Long Small Channel

Visual Experimental Study on Bubble Behavior from Nucleation Site in Vertical Rectangular Channel

The Experimental Research on Subcooled Flow Boiling in Vertical Narrow Rectangular Channels with Relatively Wide-Ranged Parameters

Experimental Investigation Of Subcooled Vertical Upward Flow Boiling In A Narrow Rectangular Channel

Study on Pressure Drop of Flow Boiling in a Rectangular Microchannel

Heat Transfer Characteristics And Flow Pattern Visualization For Flow Boiling In A Vertical Narrow Microchannel

Experimental Study of the Effect of Surface Roughness on the Heat Transfer Characteristics of Subcooled Flow Boiling in a Narrow Rectangular Channel