Abstract:In order to achieve the ultra-clean emission standards, many power plants in China have completed the installation of low-low temperature flue gas system. However, during the operation of this system, many problems have emerged, such as the ash deposition problem in the heat exchanger and dry ESP (electrostatic precipitator). In this paper, the fixed adsorption system and entrained flow experimental system were built to study the ash deposition characteristics in low-low temperature flue gas system under different temperatures and particle sizes. The repose angle was measured to evaluate the flowability and adhesion capacity of ash particles. The results show that as the increase of adsorption time, the particle size increased gradually, and the agglomeration effect is attenuated after the particles have reached adsorption saturation. The time at which the ash particles began to agglomerate with each other was defined as the agglomeration threshold. As the adsorption temperature decreased, the particle size growth rate increased. The smaller the size of ash particles, the more significant the agglomeration effect. Large particles were easy to adsorb small particles, but the agglomeration effect between large particles was weak. In addition, in the initial stage of particle agglomeration, it was mainly included the adhesion between smaller particles and the adhesion of smaller particles on the surface of large particles. The followability of the ash particles was greatly reduced after the adsorption and agglomeration process. The repose angle of the ash particles increased as the temperature of the flue gas decreased. The smaller the particle size, the larger the repose angle changes, and the more pronounced the repose angle is influenced by the adsorption temperature. The flue gas temperature cannot be blindly dropped in pursuit of high sulfur oxide removal efficiency and dust removal efficiency.

Experimental Study on Pressure Drop Characteristic of Wet Air with Ash Particles in A Horizontal Tube Bundle Heat Exchanger

Experimental Study on Pressure Drop and Heat Transfer Characteristics of Wet Air with Ash Particles across Circular Finned Tube Bundles

Experimental Study on Ash Deposition Characteristics of Dryer Exhaust along Horizontal Tube Bundles Using Digital Imaging Techniques

Effect of Ash Particles on Heat Transfer Characteristics of Condensing Heat Exchangers

Convection–condensation Heat Transfer Characteristics of Air/water Vapor Mixtures with Ash Particles along Horizontal Tube Bundles

Experimental Investigation on Evaporation Heat Transfer and Pressure Drop Characteristics of HFC-161 in a Horizontal Smooth Tube

Experimental Research on Convection–condensation Heat Transfer Characteristics and Sootblowing Operation Strategy of Waste Heat Recovery Heat Exchanger for Dryer Exhaust

Experimental Study on Ash Deposition Characteristic of Convection Heating Surface in Waste Heat Boiler

Air-side Heat Transfer Characteristics under Wet Conditions at Lower Ambient Pressure of Fin-and-tube Heat Exchanger

Study on the Heat and Mass Transfer Characteristics of Wet Air and Solution on the Surface of Corrugated Packings at Lower Ambient Pressure

Experimental Investigation on Particle Deposition and Pressure Drop Characteristics of Slit Fin-and-tube Heat Exchanger

Heat transfer and pressure drop characteristics of 3-D finned tube heat exchanger in ash-laden flue gas

An Experimental Study on Ash Deposition Problem of Low-Low Temperature Flue Gas System

Experimental study on the ash deposition and heat transfer characteristics of a heat pipe air preheater

Experimental Study on Water Recovery and Heat Transfer Characteristics of Lignite Drying Exhaust

Numerical Investigation on the Coupling of Ash Deposition and Acid Vapor Condensation on the H-type Fin Tube Bank

Influence of Wet-Particle Deposition on Air-Side Heat Transfer and Pressure Drop of Fin-and-tube Heat Exchangers

Experimental Study on the Ash Deposition Characteristics of Heat Exchanger Tubes With Honeycomb Structure

An Investigation on Heat Transfer Characteristics of Different Pressure Steam-Water in Vertical Upward Tube

Experimental Research of CFB Ash Deposition on Helical Finned Tubes

Experimental Investigation on Heat Transfer Characteristics of Smooth Tube with Downward Flow