Abstract:There is interest in exporting carbon-neutral liquid hydrogen (LH2) as a replacement for fossil fuels. However, transporting LH2 for maritime export is made difficult by the requirement for high performance insulation to reduce pressure rise and cargo losses through venting. One method to reduce boil-off losses is to allow the tank to self-pressurise along the journey and delay venting by increasing the tank maximum allowable working pressure (MAWP). To assess this, an analytical model was developed, in Matlab, to predict pressure rise and boil-off gas (BOG) generation. Perlite insulation was modelled using analytical expressions for temperature-dependent specific heat capacity and thermal conductivity. The model was tuned over a range of data, including for pressure and boil-off rate. This model was used to assess an LH2 carrier carrying four 40,000 m3 spherical tanks insulated with evacuated perlite. At atmospheric pressure, a loss rate of 0.04 % per day was predicted for the laden voyage. Over a voyage duration of 15 days the model predicts that boil-off can be reduced by 31 % when the tank is allowed to self-pressurise to 5 kPaG. This is primarily due to a reduced rate of boil-off as the liquid transitions from a subcooled to a saturated state. At higher pressures, the delay in venting was observed to be a major contributor to reduction in boil-off, with a reduction of 91 % in losses at MAWP of 60 kPaG. Pressure rise was observed to be significantly greater than a saturated liquid model would suggest, particularly at high fill levels. Finally, an empirical equation for the pressure rise was fitted to 27 data points from the literature, allowing for quick estimates of the pressure rise based on the fill level, the Rayleigh number and the surface to volume ratio in the ullage. This study suggests very low loss storage of LH2 can be achieved in large double-wall tanks over a sufficiently short journey, with only marginal pressurisation. Additional investigations on the effect of ship motion on phase change within the tank will be required to fully understand design considerations for LH2 storage tanks.

Experimental Measurements and Evaluation of the Expanded Water Repellent Perlite Used for the Cargo Containment System of LNG Carrier

Study on damaged expanded water-repellent perlite insulation integrating neural network and simulation on temperature field and Boil-off Rate in a Liquefied Natural Gas Cargo Containment

Improving the Stability of High Expansion Foam Used for LNG Vapor Risk Mitigation Using Exfoliated Zirconium Phosphate Nanoplates

Research on Temperature Field and Thermal Stress of Liquefied Natural Gas Carrier with Incomplete Insulation

Design and Analysis of the Thermal Insulation System for a New Independent Type B LNG Carrier

Experimental study on liquid/solid phase change for cold energy storage of Liquefied Natural Gas (LNG) refrigerated vehicle

Experimental and Computational Study of the Thermal Insulation Properties of Hollow Glass Microspheres

Comparative study of three insulation materials installed on type C independent tank for offshore LNG transportation

Comparative FEM Analysis of Vacuum and Perlite Insulation Techniques on the Structural Integrity of Independent Type C Liquefied Natural Gas Tank

Nonlinear Response of Partial Ship Structure Caused by Ultra-low Temperature

Numerical investigation of an ice-breaking LNGC cargo containment system based on experimental verification

Near-wall Thermal Regulation for Cryogenic Storage by Adsorbent Coating: Modelling and Pore-Scale Investigation

A Numerical Method for Analysing the Responses of Cargo Containment System of an LNGC under Iceberg Collision

Experimental Investigation on Ice Resistance of an Arctic LNG Carrier under Multiple Ice Breaking Conditions

Preparation and Performance of the Rigid Polyurethane Foams for Cargo Containment System of LNGC

Experimen on cold storage with phase change based on LNG low temperature refrigerated vehicle

Design of Thermal Insulation for Lng Tanker

Numerical study on plume characteristics of liquefied natural gas spills

Thermodynamic modelling of pressurised storage and transportation of liquid hydrogen for maritime export

Experimental Measurements for the Effective Thermal Conductivity of Pebble Beds with Uncertainty Analysis

THE STUDY ON THE ADIABATIC PERFORMANCE OF THE DILATED PERLITE IN THE HEAT TRANSFER UNDER STEADY OR UNSTEADY STATE