Abstract:LNG-fueled vehicle has been regarded as a promising substitute of the diesel vehicle owing to its clean burning characteristics. Especially for refrigerated vehicles, an additional advantage is that recovering of the LNG cold energy during vaporization will provide the refrigerating effect and therefore reduce the engine power used to drive the conventional vapor compression system (VCS). This study focuses on analysis of the feasibility of a self-refrigerated vehicle by recovering the cold energy of LNG fuel. A prototype of a self-refrigerating system was constructed and its refrigeration performance has been investigated experimentally. The interrelations of the refrigerating temperature, the cooling capacity and the consumption rate of LNG fuel were studied. The temperature field uniformity and the temperature falling characteristics of the refrigerated compartment were discussed in this paper. The experiment results showed that the refrigerating temperature of the compartment could be kept lower -20 degrees C when the LNG consumption rate is larger than 5.607 kg/h. On the basis of the theoretical analysis, this value of LNG consumption rate could be achieved when the power output of the engine (CY4102CNG) for the LNG-fueled refrigerated vehicle is more than one third of its maximum output power (75 kW) under the full-load operating condition. The original mechanical refrigeration unit (Carrier Viento 200) could be totally substituted by the proposed self-refrigerating system under this condition. Furthermore, the study on the temperature dropping and temperature field uniformity characteristics of the refrigerated compartment showed that a satisfactory result can be achieved. (C) 2014 Elsevier B.V. All rights reserved.

Experimental study on liquid/solid phase change for cold energy storage of Liquefied Natural Gas (LNG) refrigerated vehicle

Experimen on cold storage with phase change based on LNG low temperature refrigerated vehicle

Numerical Investigation of Heat Transfer Characteristics in a Shell- And-Tube Latent Heat Thermal Energy Storage System

Simulative and experimental research on the heat exchanger for cold energy recovery of liquefied natural gas

Theoretical and Experimental Study on a Self-Refrigerating System for LNG-fueled Refrigerated Vehicles

Experimental Study on a Self-Refrigerated Auto Air Conditioning System Based on LNG-fuelled Trucks

Low temperature phase change material for cold storage and its application to refrigerated transportation

Theoretical and Steady Experimental Investigation of the Cold Energy Recovering of a LNG-Fueled Refrigerated Truck

Simulation research on PCM freezing process to recover and store the cold energy of cryogenic gas

Experimental investigation of thermal performance in a shell-and-tube phase change thermal energy storage unit with an inner square tube

Near-wall Thermal Regulation for Cryogenic Storage by Adsorbent Coating: Modelling and Pore-Scale Investigation

Thermal performance analysis of a flat slab phase change thermal storage unit with liquid-based heat transfer fluid for cooling applications

Experimental research and numerical simulation of the thermal performance of a tube-fin cold energy storage unit using water/modified expanded graphite as the phase change material

Cold Energy Utilization Analysis of Cryogenic Dual-Energy Heavy-Duty Trucks Coupled LH2/LNG Cooled Shield

Process Comparison of Low Temperature Cold Store Using LNG Cold Energy

Thermodynamic Analysis on the Process of Regasification of LNG and Its Application in the Cold Warehouse

Power generation and recovery of higher hydrocarbons utilising cold energy during LNG regasification

Experimental and numerical analysis of the chill-down process of a large horizontal cryogenic storage tank

Experimental investigation on RORC system performance for recovering LNG cold energy under heating and cooling capacities variations

Experimental investigation into storage of confined cryogenic liquids without evaporation venting

Research on LNG Vehicle Refrigeration Using Waste Cold Energy