Abstract:The traditional choice of insulation material for offshore LNG transportation with type C independent tank was polyurethane foam (PUF). However, aiming to further cut down the insulation cost and spare additional arrangement space, the requirement of searching for the alternative materials still exists. Polyisocyanurate board (PIRB) and silica aerogel blanket (SAB) are chosen as candidates in this study since these two materials have been proved to be available in other fields. Despites their advantages, the seams and joints due to the specific installation techniques for PIRB and SAB could be the causes of potential defects when transporting cryogenic liquid. In this paper, the comparative study of three materials associated with their specific installation techniques was conducted to discuss if PIRB and SAB are available for offshore LNG transportation. Therein, the insulation performances were investigated through the evaporation experiment of LN2 with a 1.5 m3 type C experimental tank. The equivalent conductive model was adopted in the numerical analysis with finite element method (FEM) to determine the temperature field of insulation and the absorbed heat from the LN2 evaporation. It is proved that three types of insulation materials are well behaved and available for transporting cryogenic liquid. In respect of the thermal resistance, the ranking of three types of insulation materials is: SAB, SPF and PIRB. Higher thermal resistance of insulation leads to thinner thickness and additional arrangement space in the cargo hold, and more ship construction cost can be cut down due to the possible scaling down of ship dimensions. However, from the perspective of insulation material cost, the cost reduction due to the insulation thickness decrease is not significant as the tank continually scales up, and it is more practical to apply SPF or PIRB on a full-scale type C independent tank.

Research on Temperature Field and Thermal Stress of Liquefied Natural Gas Carrier with Incomplete Insulation

Study on damaged expanded water-repellent perlite insulation integrating neural network and simulation on temperature field and Boil-off Rate in a Liquefied Natural Gas Cargo Containment

Finite element analysis of strength of mobile cryogenic LNG storage tank

Numerical simulation analysis of a heat transfer tube in SuperORV

A Hydrodynamical Study on Motions and Mooring Loads of the Small Scale LNG Carrier

Overall Temperature Field and Thermal Stress Analysis of 30000m3 LNG Storage Tanks

Research on Heat Dissipation Mechanism of the Power Supply in Seafloor Observation Network Junction Box

Comparative study of three insulation materials installed on type C independent tank for offshore LNG transportation

Comparative FEM Analysis of Vacuum and Perlite Insulation Techniques on the Structural Integrity of Independent Type C Liquefied Natural Gas Tank

Thermal Stress Analysis of Process Piping System Installed on LNG Vessel Subject to Hull Design Loads

Experimental Study of Ship Motion Effect on Pressurization and Holding Time of Tank Containers during Marine Transportation

Study on thermodynamic response in liquefied natural gas storage tanks under static pressurization and sloshing conditions

Fuel Gas Supply System in a LH2-Fueled Ship

Temperature Field Analysis of LNG Tank under Ultra-Low Temperature Based on Finite Element Method

Insulation calculation for LNG spherical tank

Structural Characteristics of Corrugated Steel Inner Walls in Liquefied Natural Gas Ship Membrane Compartments

Thermal Stress Analysis of the LNG Corrugated Cryogenic Hose During Gas Pre-Cooling Process

Analysis of convection and boil-off in multi-scale membrane LNG tanks under sloshing excitations

Failure research of T-joint at liquefied natural gas tanker

Multiphase-thermal flow simulation in a straight vacuum-insulated LH2 pipe: Cargo handling system in LH2 carrier

Experimental Study on the Effect of Extreme Waves on a LNG Carrier