Abstract:The phase equilibrium of Mg-Cu-Ca ternary system at 350 degrees C were investigated using thirteen key samples. Scanning electron microscopy (SEM) equipped with energy-dispersive spectroscope (EDS) was employed to investigate equilibrium relationships and phase compositions in alloy samples. Powder X-ray diffraction (XRD) technique was used to analyze the crystal structures of new found phases. Two unreported ternary phases, P1 and Mg25-xCu75Cax were observed and investigated for the first time. The compound P1 has a narrow solid homogeneity ranged from about Mg25Cu35Ca40 to Mg30Cu30Ca40 (in at. %). The solid solubility limit of the compound Mg25-xCu75Cax was found to be 8.03 <= x(Ca) <= 16.67 with constant value of about 75 at. % Cu at 350 degrees C. The 2q of fourteen diffraction peaks of new phase P1 were determined to be 23.0 degrees, 35.9 degrees, 37.3 degrees, 38.9 degrees, 42 degrees, 44 degrees, 47 degrees, 52.5 degrees, 54 degrees, 56.7 degrees, 62.3 degrees, 66.8 degrees, 68.2 degrees and 75.4 degrees. The 2q of ten diffraction peaks of the new compound Mg25-xCu75Cax were confirmed to be 20.5 degrees, 21.2 degrees, 34.7 degrees, 35.7 degrees, 42.3 degrees, 43.3 degrees, 44.8 degrees, 47.3 degrees, 50.5 degrees and 74.5 degrees. The maximum solid solubility of Ca in the terminal compound MgCu2 was found to be 8.83 at. % at 350 degrees C. Ternary maximum solid solubility of binary terminal compounds Mg2Ca, Mg2Cu, Cu5Ca and CuCa were less than 2 at. %. In addition, eight three-phase equilibrium relationships were determined in the present work. (C) 2019 Elsevier B.V. All rights reserved.

Experimental and Thermodynamic Study of the Mg-Sn-Ca-Sr Quaternary System: Part I-Mg-Sn-Ca Ternary System

Experimental Investigation and Thermodynamic Modeling of the Mg–Sn–Sr Ternary System

Thermodynamic Re-Assessment of the Mn-La Binary System

Experimental investigation and thermodynamic modeling of the Mg-Cu-Ca ternary system

Thermodynamic Descriptions of the Quaternary Mg–Al–Zn–Sn System and Their Experimental Validation

Experimental Determination of the Phase Equilibrium in the Mg–Cu–Ca Ternary System at 350 °C

The Structural, Elastic And Thermodynamic Properties Of Intermetallic Phases In Mg-Sn-Si-Ca(Sr) Alloys: A First-Principles Study

Thermodynamic study of the Ca-Cu-Zn ternary system with key experimental measurements

Re-investigation of the Phase Equilibria and Thermodynamic Assessment of the Mg-Sm Binary System

Thermodynamic description and simulation of solidification microstructures in the Cu–Mg–Zn system

Investigation on the crystal structure and mechanical properties of the ternary compound Mg11-xZnxSr combined with experimental measurements and first-principles calculations

Liquidus Projection and Thermodynamic Modeling of Sn–Zn–Cu Ternary System

Thermodynamic Reassessment of the Binary Cu-Sn, Cu-P, and Sn-P and Ternary Cu-Sn-P Systems

Thermodynamic properties and primary phase structures of ternary Cu90−xSnxSb10 alloys investigated by differential scanning calorimetry and laser flash method

Thermodynamic descriptions of quaternary Mg–Al–Zn–Bi system supported by experiments and their application in descriptions of solidification behavior in Bi-additional AZ casting alloys

Critical Evaluation and Thermodynamic Modeling of the Ag-X (x=mn, Y, Sr) Binary Systems

A coupled experimental and thermodynamic assessment of the Mg-Bi-Sb and Zn-Bi-Sb ternary system and extrapolate to the Mg-Bi-Zn-Sb system

Experimental Investigation of Isothermal Sections and Thermodynamic Modeling on the Cu-Nb-Ni System

Phase Equilibria of Sn–Sb–Cu System

Experimental Measurement on the Phase Equilibria of the Mg–Ag–Cu Ternary System at 350 and 400 °C

Thermodynamic Description of the Cu–Sn System