Abstract:To master the pollutant emission characteristics of a 350 MW supercritical CFB boiler under mixed combustion of multi-element low-calorific value coal including coal slime and coal gangue, taking a 350 MW supercritical CFB boiler of a power plant as the research object, and based on the measured data of on-site operation, the formation and emission characteristics of SO 2 , NO x and dust in flue gas were studied against the boiler load rate between 30% and 99%. Additionally, the key operated parameters including boiler operating load, average bed temperature, excess air coefficient and fluidizing air rate on its generation and emission level were investigated. The test results reveal that the flue gas pollutant emissions of the CFB unit can meet the emission standards within the load range of 30%-99% at total discharge outlet. The emission concentration of SO 2 , NO x basically decreases first and then increases rapidly with the decrease of boiler load. The concentration of dust emission decreases with the decrease of boiler load, and the dust emission concentration decreases with the reduction of boiler load. Among the key operating parameters studied, the boiler bed temperature plays a leading role in the emission level of SO 2 , NO x . The emission concentration of SO 2 and NO x is higher with the lower average bed temperature and the larger excess air coefficient, and the emission concentration is basically positively correlated with the excess air coefficient and fluidization air rate. Considering comprehensively, it is recommended that the average bed temperature of the boiler should be properly controlled above 800 ℃, and the excess air coefficient should be stabilized less than 1.3. The way of flue gas recirculation can be used to reduce the oxygen concentration of the flue gas under low load on the basis of the maintaining the normal fluidization of the material.

Gas Concentration Profiles in the Furnace of CFB Boilers

Gas concentration profiles in the furnace of large CFB boilers with water-cooled square separator

Influence of Secondary Air Distribution on the Gas-solid Mixing and Combustion Condition in a CFB (circulating Fluidized Bed) Boiler Furnace

Measurement of Heat Transfer in a 465t/h Circulating Fluidized Bed Boiler

Emission characteristics test of SO2,NOx and dust from a 350 MW super-critical circulating fluidized bed boiler

Experimental Study on Post Combustion Characteristics of the Imported 300 MW Circulating Fluidized Bed Boiler

Heat flux profile of the furnace wall of a 300MWe CFB boiler

Combustion characteristics of the external circulation loop on Baima's 300 MWe circulating fluidized bed boiler

Experimental study on secondary air mixing along the bed height in a CFB with a multi-tracer-gas method

The Fundamental Studies on Combustion of Sintering Flue Gas in Circulating Fluidized Bed

Study on the contamination coefficient of convective heating surface in a circulating fluidized bed boiler

Atmospheric Hot-test on Gas Concentration Distribution in the Opposed Multi-burner Coal Water Slurry Gasifier

Lateral Gas Mixing In The Freeboard Zone Of A Cfb Boiler

Field Tests on Combustion Uniformity of the Dilute Phase in a 600MW Supercritical CFB Boiler

Density Distribution in the Furnace in 75 T/h CFB Boiler with Water Cooled Square Separator

CFD Modeling of Oxy-Coal Combustion in Circulating Fluidized Bed

Simulation of biogas co-combustion in CFB boiler: Combustion analysis using the CPFD method

Characteristics of Chemical Composition and Particle Size Distribution from Real Coal-fired Circulating Fluidised Bed (CFB) Boiler

Effects of Different Factors on Sulfur Trioxide Formations in a Coal-Fired Circulating Fluidized Bed Boiler

Measurement of particle density distribution near water wall of a 330 MW unit CFB boiler

The Investigation of the Coal Ignition Temperature and Ignition Characteristics in an Oxygen-Enriched FBR