Abstract:The surge in air pollution and respiratory diseases across the globe has spurred significant interest in the development of flexible gas sensors prepared by low-cost and scalable fabrication methods. However, the limited breathability in the commonly used substrate materials reduces the exchange of air and moisture to result in irritation and a low level of comfort. This study presents the design and demonstration of a breathable, flexible, and highly sensitive NO2 gas sensor based on the silver (Ag)-decorated laser-induced graphene (LIG) foam. The scalable laser direct writing transforms the self-assembled block copolymer and resin mixture with different mass ratios into highly porous LIG with varying pore sizes. Decoration of Ag nanoparticles on the porous LIG further increases the specific surface area and conductivity to result in a highly sensitive and selective composite to detect nitrogen oxides. The as-fabricated Ag/LIG gas sensor on a flexible polyethylene substrate exhibits a large response of −12‰, a fast response/recovery of 40/291 s, and a low detection limit of a few parts per billion at room temperature. Integrating the Ag/LIG composite on diverse fabric substrates further results in breathable gas sensors and intelligent clothing, which allows permeation of air and moisture to provide long-term practical use with an improved level of comfort.The Supporting Information is available free of charge at https://pubs.acs.org/doi/10.1021/acsami.2c02061.Design and geometric parameters of the gas sensor; optical images of the F127/resols and corresponding LIG patterns (insets) on varying substrates; deconvoluted C 1s of the LIG prepared by the 3:2 F127/resols; SEM image of Ag-coated LIG (3:2 mass ratio) and the corresponding EDS spectrum; optical image of the four-point probe and the resulting sheet resistance measurements; current–voltage (I–V) curves of the LIG with three different F127/resol mass ratios; typical response curve of the pristine LIG gas sensor with the largest pore size to 1 ppm NO2; schematic diagram showing the sensing mechanism of the Ag/LIG composite to NO2; analysis of the peak intensity ratios of the D and 2D to G obtained from the Raman spectra; XPS analysis of the Ag 3d intensity in the Ag/LIG composite; optical images of the Ag/LIG composite on knitted fabric, Kevlar fiber, and non-woven fabric to demonstrate the large-scale production; dynamic response curves of a Ag/LIG-based gas sensor on three different fabric substrates upon exposure to NO2 ranging from 0.5 to 2.5 ppm; and comparison in the weight change between the bottles covered by the knitted fabric and that with three different Ag/LIG composites (PDF)This article has not yet been cited by other publications.

Sprayed, Scalable, Wearable, and Portable NO2 Sensor Array Using Fully Flexible AgNPs-All-Carbon Nanostructures.

Bioinspired supramolecular arrayed heterojunction-based room-temperature sensor for high-performance gas detection

Ultrasensitive flexible NO2 gas sensors via multilayer porous polymer film

Intrinsically Breathable and Flexible NO 2 Gas Sensors Produced by Laser Direct Writing of Self-Assembled Block Copolymers

Flexible Nitrogen Dioxide Gas Sensor Based on Reduced Graphene Oxide Sensing Material Using Silver Nanowire Electrode

A flexible and wearable NO2 gas detection and early warning device based on a spraying process and an interdigital electrode at room temperature

Mosaic-Like Micropatterned Monolayer RGO/AgNPs Film Gas Sensor with Enhanced Room-Temperature NO2 Response/Recovery Properties

Wearable NO<sub>2</sub> sensing and wireless application based on ZnS nanoparticles/nitrogen-doped reduced graphene oxide

Highly Sensitive, Selective, Flexible and Scalable Room-Temperature NO2 Gas Sensor Based on Hollow SnO2/ZnO Nanofibers

Highly Sensitive, Selective, Flexible and Scalable Room-Temperature NO<sub>2</sub> Gas Sensor Based on Hollow SnO<sub>2</sub>/ZnO Nanofibers

A High Response Three-Dimensional Ag Nanoparticles/Rgo Microtubular Field Effect Transistor Sensor for No<inf>2</inf> Detections

A High Response Three-Dimensional Ag Nanoparticles/Rgo Microtubular Field Effect Transistor Sensor For No2 Detections

A Novel Three-Dimensional Ag Nanoparticles/reduced Graphene Oxide Microtubular Field Effect Transistor Sensor for NO2 Detections

Amorphous SiO2-based All-Inorganic Self-Supporting Nanofiber Membrane: A Flexible and Breathable Sensing Platform for NO2 Detection

A novel three-dimensional Ag nanoparticles/reduced graphene oxide microtubular field effect transistor sensor for NO2 detections.

A Flexible Gas Sensor Based on Single-Walled Carbon Nanotube-Fe2o3 Composite Film

Wearable Inorganic Oxide Chemiresistor Based on Flexible Al2O3-Stabilized ZrO2 Ceramic Sponge Substrate for NO2 Sensing

High Performance Acoustic Wave Nitrogen Dioxide Sensor with Ultraviolet Activated 3D Porous Architecture of Ag-Decorated Reduced Graphene Oxide and Polypyrrole Aerogel

AgNPs with CNTs to construct multifunctional flexible sensor with dual conductive network structure

Ti3C2Tx Nanosheet/Bi2S3 Nanobelt Composites for NO2 Gas Sensing

Intrinsically Flexible CNT-TiO2-Interlaced Film for NO Sensing at Room Temperature