Abstract:H doping can enhance the performance of ZnO thin-film transistors (TFTs) to a certain extent, and the design of double active layers is an effective way to further improve a device’s performance. However, there are few studies on the combination of these two strategies. We fabricated TFTs with ZnO:H (4 nm)/ZnO (20 nm) double active layers by magnetron sputtering at room temperature, and studied the effect of the hydrogen flow ratio on the devices’ performance. ZnO:H/ZnO-TFT has the best overall performance when H2/(Ar + H2) = 0.13% with a mobility of 12.10 cm2/Vs, an on/off current ratio of 2.32 × 107, a subthreshold swing of 0.67 V/Dec, and a threshold voltage of 1.68 V, which is significantly better than the performance of single active layer ZnO:H-TFTs. This exhibits that the transport mechanism of carriers in double active layer devices is more complicated. On one hand, increasing the hydrogen flow ratio can more effectively suppress the oxygen-related defect states, thus reducing the carrier scattering and increasing the carrier concentration. On the other hand, the energy band analysis shows that electrons accumulate at the interface of the ZnO layer close to the ZnO:H layer, providing an additional path for carrier transport. Our research exhibits that the combination of a simple hydrogen doping process and double active layer construction can achieve the fabrication of high-performance ZnO-based TFTs, and that the whole room temperature process also provides important reference value for the subsequent development of flexible devices.

Effect of Al Doping on Performance of ZnO Thin Film Transistors

Properties of Al-doped ZnO film transistors with different source and drain electrodes

Al-Doped Zno Thin-Film Transistors on Flexible Plastic Substrate

Effect Of O-2 Incorporation During The Channel Fabrication Process On Aluminum-Doped Zinc Oxide Thin-Film Transistor Characteristics

Atomic Layer Deposition Deposited Al-Doped ZnO Films for Transistor Application

Atomic Layer Deposition of Al-Doped ZnO Contacts for ZnO Thin-Film Transistors

Effect of Film Thickness on Properties of Al-Doped Zno Film As Transparent Conducting Electrodes in Oleds

Investigation on Transparent, Conductive ZnO:Al Films Deposited by Atomic Layer Deposition Process

Feasibility of Atomic Layer Deposited AlZrOx Film to Achieve High Performance and Good Stability of ZnSnO-TFT

Enhanced Stability Performance of Transparent Ozone ALD ZnO Thin-Film Transistors with SiAlO X Dielectric

High Performance Ti-Doped ZnO TFTs with AZO/TZO Heterojunction S/D Contacts

Characteristic research of zinc oxide based thin film transistor by ALD technology

Performance enhancement of ATZO TFTs by component control and post treatment

High Performance Aluminum-Doped Zno Thin Film Transistors with High-K Gate Dielectrics Fabricated at Low Temperature

P‐1.7: Atomic‐Layer‐Deposition Deposited Superlattice‐Structure Al‐Zn‐O Films for Thin Film Transistors Application

Enhanced Performance of ZnO Thin-Film Transistors with ZnO Dual-Active-layer

High-Performance Flexible Tin-Zinc-Oxide Thin-Film Transistors Fabricated on Plastic Substrates

Effects of Al Doping on the Properties of ZnO Thin Films Deposited by Atomic Layer Deposition

High-Performance Thin-Film Transistors with ZnO:H/ZnO Double Active Layers Fabricated at Room Temperature

High-Performance Al–Sn–Zn–O Thin-Film Transistor with a Quasi-Double-Channel Structure

Influence of Ga Doping on Electrical Performance and Stability of ZnO Thin-Film Transistors Prepared by Atomic Layer Deposition