Abstract:Al2O3, as one of the gate dielectric materials for thin film transistors (TFTs), has been extensively investigated because of its large bandgap, high breakdown field, and good thermal stability. However, the further development of Al2O3 thin films is limited by the presence of defects such as oxygen vacancies, self-interstitial atoms, or impurity elements. To overcome this obstacle, we have developed a novel method for fabricating Al2O3 thin films by using the atomic layer deposition (ALD) technique. This method replaces the conventional Trimethylaluminium (TMA)/H2O cycles with TMA/TMA/H2O/H2O cycles (referred to as ‘double cycles’), to deposit the Al2O3. The 5-nm ultrathin Al2O3 film showed a high areal capacitance of 660 nF/cm2 at 20 Hz, and a relatively low current density of 10−8 A/cm2 at 1 MV/cm. InGaZnO (IGZO) TFTs with ultrathin Al2O3 gate dielectric grown by double cycles exhibited outstanding performances, such as a near theoretical limit subthreshold swing (SS) of 70 mV/decade, a higher on/off current ratio $(I_{\mathrm{ on}} / I_{\mathrm{ off}}$ ) of 106, an increased field-effect mobility ( $\mu $ ) of 6.5 cm2/Vs, a lower threshold voltage $(V_{\mathrm{ th}})$ of 0.2 V, and a low operating voltage of 3 V. These results are superior to the IGZO TFTs with Al2O3 dielectrics deposited using the single TMA/H2O cycle. Therefore, the implementation of ‘double cycles’ in the fabrication of dielectrics through ALD demonstrates considerable potential for future application in low-power electronic devices.

Feasibility of Atomic Layer Deposited AlZrOx Film to Achieve High Performance and Good Stability of ZnSnO-TFT

Highly Stable Atomic Layer Deposited Zinc Oxide Thin-Film Transistors Incorporating Triple O 2 Annealing

Enhanced Stability Performance of Transparent Ozone ALD ZnO Thin-Film Transistors with SiAlO X Dielectric

Stability Enhancement of Low Temperature Thin-Film Transistors with Atomic-Layer-Deposited Zno:Al Channels

High-Performance ZnO Thin-Film Transistors Prepared by Atomic Layer Deposition

High-performance ZnO Thin-Film Transistors Prepared by Atomic Layer Deposition at Low Temperature

High-Performance Thin-Film Transistors with ZnO/Al2O3 Superlattice Channel Fabricated by Atomic Layer Deposition

P‐1.11: High‐mobility ZnO thin‐film transistors with HfO<sub>2</sub>/Al<sub>2</sub>O<sub>3</sub> bilayer dielectric

Performance Optimization of Atomic Layer Deposited ZnO Thin-Film Transistors by Vacuum Annealing

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al2O3 Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al<sub>2</sub>O<sub>3</sub> Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al₂O₃ Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

Performance Improvement of Atomic Layer-Deposited ZnO/Al2O3Thin-Film Transistors by Low-Temperature Annealing in Air

Atomic Layer Deposition Deposited Al-Doped ZnO Films for Transistor Application

Effect of Al Doping on Performance of ZnO Thin Film Transistors

Enhanced Performance of Atomic Layer Deposited Thin-Film Transistors with High-Quality ZnO/Al 2 O 3 Interface

High-Performance Flexible ZnO Thin-Film Transistors by Atomic Layer Deposition

P‐1.7: Atomic‐Layer‐Deposition Deposited Superlattice‐Structure Al‐Zn‐O Films for Thin Film Transistors Application

Atomic Layer Deposition of Al-Doped ZnO Contacts for ZnO Thin-Film Transistors

Enhanced Performance of ZnO Thin-Film Transistors with ZnO Dual-Active-layer

Al-Doped Zno Thin-Film Transistors on Flexible Plastic Substrate