Abstract:This paper reports a novel capacitive sensing method, enabling accurate and self-calibrated measurements for both the amplitude and phase information in sinusoidal motion. The approach constructively utilizes the inherent nonlinearity of a triangular-electrode based (TEB) variable-area sense capacitor. In the case of TEB detection signal, two harmonics exist and each carries information about the motional amplitude and phase. The TEB method robustly extracts the motional amplitude from the ratio of two sideband amplitudes and extracts the motional phase from the subtraction of two sideband phases. This technique is especially valuable for capacitive detection of periodic motion in MEMS resonant devices, such as the resonant accelerometer and Coriolis vibratory gyroscope. The paper presents detailed theoretical analysis and proposes a real-time measurement algorithm implemented in an FPGA device. Experimental results manifest that, compared with the traditional linear method, the sensitivity of the measured amplitude and phase to system parameter variations is highly suppressed up to 95%. Furthermore, an oscillation control system with TEB capacitive detection is introduced for micro-machined vibratory gyroscopes. First measurement results show the amplitude variance of the drive displacement is 120 ppm in an hour while the phase variance is 80 ppm. Allan variance analysis indicates a bias instability of 6.5 degrees/h for the gyroscope output. (C) 2016 Elsevier B.V. All rights reserved.

Three-Axis Capacitive SOI Accelerometer Using Combination of In-Plane and Vertical Comb Electrodes

A Three-Axis SOI Accelerometer Sensing with Both In-Plane and Vertical Comb Electrodes

A Planar Capacitive Sensor for Large Scale Measurement

A novel SOI-based single proof-mass 3-axis accelerometer with gap-closing differential capacitive electrodes in all sensing directions

A two degrees of freedom comb capacitive-type accelerometer with low cross-axis sensitivity

A 3-axis MEMS capacitive accelerometer free of cross axis sensitivity

Compact Electrode Design for an In-Plane Accelerometer on SOI with Refilled Isolation Trench

A Novel Triangular-Electrode Based Capacitive Sensing Method for MEMS Resonant Devices

A silicon-on-glass Z-axis accelerometer with vertical sensing comb capacitors.

A Novel Soi Z-axis Accelerometer with Gap Closing Differential Sensing Electrodes

Poly-Si Based Two-Axis Differential Capacitive-Sensing Accelerometer

Silicon-On-Insulator Out-Of-Plane Electrostatic Actuator with in Situ Capacitive Position Sensing

Simulation Analysis on Characteristics of a Planar Capacitive Sensor for Large Scale Measurement

A poly-Si based 2-axis differential capacitive-sensing accelerometer

Implementation of A Gap-Closing Differential Capacitive Sensing Z-Axis Accelerometer on an Soi Wafer

3-axis Capacitive Low-Gravity MEMS Accelerometer with Zero Cross-Axis Sensitivity in a Commercial Process

Compact electrode design for in-plane accelerometer on SOI with refilled isolation trench

New capacitive low-g triaxial accelerometer with low cross-axis sensitivity

Design and Fabrication of A Torsional Z-Axis Capacitive Accelerometer with Novel Comb Capacitor

Design and simulation of a novel MEMS-based single proof mass three-axis piezo-capacitive accelerometer

Flexible Capacitive Tactile Sensor Array with Truncated Pyramids As Dielectric Layer for Three-Axis Force Measurement