Abstract:A novel design of the gas inlet system in a diamond microwave plasma chemical vapor deposition growth chamber has been reported in this paper. The design is targeting for high-quality, high-speed, and high-efficiency diamond material fabrication. By introducing a gas inlet hole into the susceptor, we expand the ways of gas introduction for diamond growth. After extensive numerical and experimental investigation, we have found that the introduction of methane and doping gas inlet from the hole of below while the hydrogen from the top is feasible for realizing the target. The growth and doping species could be confined around the substrate, making efficient usage of the precursors. The plasma state change caused by the difference of the gas inlet modes has been ascribed to the resulted gas distribution in the chamber. The measured growth rate has been increased to 32 μm/h, which is 16 times higher than traditional gas inlet configuration. Meanwhile, a large improvement of the nitrogen doping concentration has been achieved. Besides, with the increase of growth rate and nitrogen incorporation efficiency, the crystal quality and surface morphology keep in an acceptable degree. In this mode, the dual gas flow system can perfectly solve the contradiction among the crystal quality, growth rate, and doping efficiency, commonly existing during the material fabrication process, the chamber contamination could be significantly suppressed due to the constrained distribution of methyl and doping species, making the fabrication cost much lower. The results of repetitive experiments indicate that other residual impurities present in the chamber of MPCVD could likely regulate the threshold concentration of nitrogen required for accelerating the growth rate during the nitrogen doped diamond growth, which have a significant effect on the diamond growth.

Enhanced Growth Of High Quality Single Crystal Diamond By Microwave Plasma Assisted Chemical Vapor Deposition At High Gas Pressures

Large Area Single-Crystal Diamond Synthesis by 915 MHz Microwave Plasma-Assisted Chemical Vapor Deposition

Very high growth rate chemical vapor deposition of single-crystal diamond.

Single crystal diamond growth by MPCVD at subatmospheric pressures

Recent advances in high-growth rate single-crystal CVD diamond

Growth of single-crystal diamond by microwave plasma CVD with high precursor utilization using cyclic gas injection and control of carbonaceous species content with optical emission spectroscopy

Developments in synthesis, characterization, and application of large, high-quality CVD single crystal diamond

Homoepitaxy Growth of Single Crystal Diamond under 300 torr Pressure in the MPCVD System

An innovative gas inlet design in a microwave plasma chemical vapor deposition chamber for high-quality, high-speed, and high-efficiency diamond growth

High-rate growth of single-crystal diamond with an atomically flat surface by microwave plasma chemical vapor deposition

Enhanced optical properties of chemical vapor deposited single crystal diamond by low-pressure/high-temperature annealing

Enhanced deposition rate of polycrystalline CVD diamond at high microwave power densities

Microwave power and chamber pressure studies for single-crystalline diamond film growth using microwave plasma CVD

Epitaxial lateral growth of single-crystal diamond under high pressure by a plate-to-plate MPCVD

Short-pulse excitation of microwave plasma for efficient diamond growth

High-speed growth of high-quality polycrystalline diamond films by MPCVD

Mechanical properties of high-crystalline diamond films grown via laser MPCVD

Fast, Efficient Tailoring Growth of Nanocrystalline Diamond Films by Fine-Tuning of Gas-Phase Composition Using Microwave Plasma Chemical Vapor Deposition

Rapid Growth of Nanocrystalline Diamond on Single Crystal Diamond for Studies on Materials under Extreme Conditions

Effect of pressure on nanocrystalline diamond films deposition by hot filament CVD technique from CH4/H2 gas mixture

Recent progress in homoepitaxial single-crystal diamond growth via MPCVD