Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

Self-heating Enhanced HCI Degradation in Pldmosfets

Understanding of Self-Heating Enhanced Degradation in Pldmosfets by MR-DCIV Method

Understanding of HCI degradation temperature dependence in SOI STI-pLDMOSFETs from MR-DCIV spectroscopy

Layout dependent hot-carrier-injection-induced pLDMOS degradation from a non-destructive characterization viewpoint

Research of Hot-carrier-induced Degradation on SOI NLIGBT

Understanding the correlation of HCI and NBTI degradation in pLDMOSFETs from MR-DCIV technique

Deep Insight of Self-Heating Effect Induced Hot Carrier Reliability Improvement in LDMOS Devices

Investigation on Hot-Carrier-induced Degradation of SOI NLIGBT.

PBTI and HCI Degradations of Ultrathin Body InGaAs-On-Insulator Nmosfets Fabricated by Wafer Bonding

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

The Impact of Self-Heating on HCI Reliability in High-Performance Digital Circuits

The Device Instability of p-GaN Gate HEMTs Induced by Self-Heating Effect Investigated by on-State Drain Current Injection (DCI) Technique

Issues And Controversies In Nbti Degradation And Recovery Mechanisms For P-Mosfets With Sion Gate Dielectrics

A High-Performance and Low HCI Degradation LDMOS Device With a Hybrid Field Plate

Investigation and active suppression of self-heating induced degradation in amorphous InGaZnO thin film transistors

New Insights into the HCI Degradation of Pass-Gate Transistor in Advanced FinFET Technology.

Degradation Mechanism of Short Channel P- FinFETs under Hot Carrier Stress and Constant Voltage Stress

Degradation induced by hot carrier and cold carrier in 65-nm NMOSFETs with enclosed gate and two-edged gate layouts

Analysis of Abnormal GIDL Current Degradation under Hot Carrier Stress in DSOI-MOSFETs

High temperature behavior of multi-region direct current current–voltage spectroscopy and relationship with shallow-trench-isolation-based high-voltage laterally diffused metal–oxide–semiconductor field-effect-transistors reliability

Investigation of DC Hot-Carrier Degradation at Elevated Temperatures for P-Channel Metal–Oxide–Semiconductor Field-Effect Transistors of 0.13 Μm Technology