Abstract:Silicon carbide (SiC) super junction (SJ) JFETs fabricated by sidewall implantation with different mesa-widths (MWs) and termination designs are characterized in this article. The device with an MW of $1.8 \mu \text{m}$ and active area of 0.104 mm2 achieves a breakdown voltage of 1086 V and a specific ON-resistance of 0.98 $\text{m}\Omega \,\cdot $ cm2. The first-quadrant output and transfer characteristics are presented, from which the ON-resistance and pinch-off voltage are extracted and analyzed. The pinch-off voltage shows great stability against the variation of temperature. The forward blocking characteristics under different gate voltages and with different terminations are presented. The gate needs to be negatively biased below the hold-off voltage to prevent the premature breakdown caused by drain-induced barrier-lowering (DIBL) effect. The termination with narrow mesas in the ${x}$ -direction and trapezoidal mesas in the ${y}$ -direction is found to have the highest breakdown voltage, due to its optimized net charge distribution. The third-quadrant output characteristics are presented. Under forward-off gate voltage, the third-quadrant turn-on voltage is found to be determined by the difference of hold-off and pinch-off voltages, and there is a tradeoff between the absolute third-quadrant voltage drop ( $\vert {V}_{\text{on}}\vert $ ) and the maximum current before gate junction turn-on ( ${J}_{\text{umax}}$ ). The third-quadrant performance can be improved by using forward-on gate voltage, a $\vert {V}_{\text{on}}\vert $ lower than 0.2 V (at 100 A/cm2) and a ${J}_{\text{umax}}$ larger than 500 A/cm2 are achieved. Finally, the whole output characteristics are modeled to facilitate the device design in different applications.

Characterization of Normally-off SiC Vertical JFET Devices and Inverter Circuits

Characteristics and Application of Normally-Off SiC-JFETs in Converters Without Antiparallel Diodes

Application of SiC diode in high frequency and high power current inverter

Soft-switching SiC Power Electronic Conversion for Distributed Energy Resources and Storage Applications

Normally-off SiC-JFET inverter with low-voltage control and a high-speed drive circuit

Switching Performance of Epitaxially Grown Normally-Off 4H-Sic Jfet

Sic Mosfet Zero-Voltage-Switching Svm Controlled Three-Phase Grid Inverter

Static and Dynamic Behaviour of SiC JFET/Si MOSFET Cascade Configuration for High-Performance Power Switches

Normally-off trench JFET technology in 4H silicon carbide

SiC Junction Control, an Alternative to MOS Control High Voltage Switching Devices

SiC Full-Bridge Grid-Tied Inverter with ZVS-switching

Transient analysis of Si-MOS and SiC-JFET cascode power switches

Design and Application of High-Voltage SiC JFET and Its Power Modules

A High Performance 4H-Sic Normally-off VJFET

Interleaved Flyback Micro-inverter with SiC MOSFET

Fabrication and Dynamic Switching Characteristics of 6.5kv400a SiC MOSFET Module

Current Status and Future Prospects of SiC Power JFETs and ICs.

A Normally-off Copackaged SiC-JFET/GaN-HEMT Cascode Device for High-Voltage and High-Frequency Applications

A numerical comparison between MOS control and junction control high voltage devices in SiC technology

650-V Normally-OFF GaN/SiC Cascode Device for Power Switching Applications

Characterization and Analysis of 4H-Sic Super Junction JFETs Fabricated by Sidewall Implantation