Abstract:The group-Ⅲ nitrides and their related ternary alloys have been becoming the most attractive material for light emitting diodes (LEDs) and laser diodes (LDs) in the UV and blue spectral range. However, the origins of the yellow luminescence (YL), which is commonly observed in almost undoped and n-type GaN, remain unclear. The nature and the role of initial nitridation of sapphire surface and the generation of threading dislocation (TD) are ambiguous too. It is a possible way to resolve the above problems by studying the microstructures and optical properties combining the growth conditions. In this work, two kinds of GaN films were grown by MOCVD under different initial nitridation time (180 seconds for Sample A, and 90s for Sample B). The growth temperature is about 950℃. The cross-sectional transmission electron microscope (TEM) is performed near the GaN/sapphire interface. Corresponding the growth processes, there are three zones in the GaN layer: buffer layer, zone and sound zone. There are haystack-like domains in the faulted zone, in which there are high density of extended defects. The thickness of the faulted zone is about 0.4μm. Just above this region, the defects density is reduced sharply, and the quality of the layer is improved, which is identified by electron diffraction (ED) patterns. In comparison, Sample A shows about an order lower density of extended defects than Sample B, their columnar diameter is larger and its ED pattern is sharper, too. The buffer layer of Sample B is more smooth than Sample A. The appropriate rougher morphology of the buffer layer may cause that the structural disorder between the high-temperature (HT) grown island and the buffer layer is accommodated by Frank and Shockley partial dislocations. However, the TD is likely to propagate into the HT GaN from the smooth surface of the buffer layer grown after extensively nitridation of substrate. According to the position and width of X-ray diffraction peaks of (0002) and (0004), the size of crystalline grain, D and the residual strain could be calculated. The values of(D,e in)of Sample A and B are (175nm,0.167%) and (90nm,0.141%), respectively. Small size of crystalline grain may be advantageous to relieve the lattice and thermal mismatch stress, but it lead to higher density of extended defects. The width of GaN (0002) reflections of Sample A is 4min lower than that of Sample B. This result may be due to the lower screw TD. The higher density of screw TD may widen the GaN (0002) peak in X-ray rocking curve. In room temperature PL spectra, the ratio of band-edge emission intensity to YL one of Sample A is 3 orders larger than that of Sample B. Furthermore the YL in Sample B is stronger and has fine structure, while that in Sample A is nearly invisible in the PL spectrum. The GaN epilayer with high quality exhibits almost no YL emission. It is well known that the YL corresponds to the deformed crystal structure. We assigned that the screw TD and mixed TD are attributed to the YL referring to our XRD results.

Study of the stacking faults in a-plane GaN on r-plane sapphire grown by metalorganic chemical vapor deposition

Cathodoluminescence Investigation of Stacking Faults and Dislocations in the Edge Part of Seed‐Grown M‐plane GaN Substrate

Elimination of basal-plane stacking faults in semipolar/nonpolar GaN and light emitting diodes heteroepitaxially grown on sapphire substrates

Effect of stacking faults on the photoluminescence spectrum of zincblende GaN

Crystal Defects in Gan on (0001) Sapphire

Electron microscopy analysis of GaN/GaAs cubic heterostructure grown by MBE

Study of the Defects in GaN Epitaxial Films Grown on Sapphire by HVPE

Role of the Growth Facet on the Generation and Expansion of Stacking Faults in PVT-Grown N-Type 4H-Sic Single-Crystal Boules

Study on a-Plane GaN Thin Films Growth by MOCVD and Its r-Plane Anisotropy

Correlation between Si doping and stacking fault related luminescence in homoepitaxial m-plane GaN

Microstructural and Optical Properties of GaN Films on Nitrided Sapphire Substrates

Study of (112̄0) non polar a-plane GaN on the (11-02) r-plane sapphire

Luminescence associated with stacking faults in GaN

Anisotropic Defect Structure of GaN Film Grown by MOCVD

Characteristics of the Crystalline and Luminescence Properties of A-Plane GaN Films Grown on \Gamma-Lialo2 (302) Substrates

Study of defects in LED epitaxial layers grown on the optimized hemispherical patterned sapphire substrates

Microstructure and Physical Properties of GaN Films on Sapphire Substrates

Optical, Structural, and Synchrotron X-ray Absorption Studies for GaN Thin Films Grown on Si by Molecular Beam Epitaxy

Stacking defects in GaP nanowires: Electronic structure and optical properties

Microstructural Characterization of GaN on (0001) Sapphire

Emission from Defects in Thin Gan Epilayers Grown on Vicinal 4H-Sic Substrates