Abstract:Grain sizes, impurities, and layer thicknesses in the nm-range affect the heat transport and, hence, hinder proper heat dissipation of GaN-based devices. To obtain a clear picture of heat dissipation, the mechanisms of heat transport must be linked to the structural properties of the nitride-based materials in the device. In this paper, a systematic investigation of the typical layers of GaN high-electron mobility transistor stacks was conducted by time-domain thermoreflectance analysis and Raman measurements. The analyzed layers are the AlN nucleation layer, the Al0.3Ga0.7N transition layer, the AlGaN/AlN superlattice, the C-doped GaN back-barrier, and the uid GaN layer. The results were interpreted using the Born–van Karman model, including the suppression function approach to describe the governing heat transport mechanisms. Investigation of this AlN nucleation layer showed that its phonon scattering is dominated by impurity and grain boundary scattering. The Al0.3Ga0.7N transition layer was shown to have a reduced thermal conductivity not only due to alloy scattering but also because of grain boundary scattering. The AlGaN/AlN superlattice showed a thermal conductivity lower than the Al0.3Ga0.7N transition layer, especially at higher temperatures (7.2 ± 0.2 W/mK vs 14.1 ± 0.4 W/mK at 300 °C). Caused by the enhanced AlGaN/AlN interface density, the thermal conductance was found to be 2 GW/m2 K. The AlGaN/AlN superlattice indicated an anisotropic thermal transport with a factor of ∼1.5. The C-doped GaN layers were analyzed in terms of their size-dictated thermal conductivity, resulting in a reduction of ∼66% from 1 μm to 250 nm at 30 °C. Raman spectroscopy revealed that the thicker the GaN layer, the higher the compressive stress in GaN, which additionally results in a higher thermal transport. The investigations of the heat transport depending on the structural properties enabled an accurate determination of the thermal conductivity of the layer stack. These thermal conductivities served as input parameters for 3D simulation to extract the temperature, in terms of the thermal resistance, of such high-electron mobility transistor stacks. This simulation shows the importance of the GaN layer in terms of thermal management. This work uncovers the thermal transport in GaN-based transistor stacks with the aim to improving the thermal design.

Thermal conductivity studies of a GaN-sapphire structure by combined scanning thermal microscopy and electron backscatter diffraction

Effects of Surface/interface Stress on Phonon Properties and Thermal Conductivity in AlN/GaN/AlN Heterostructural Nanofilms

Molecular dynamics study on the dependence of thermal conductivity on size and strain in GaN nanofilms

Effect of Stress-Dependent Thermal Conductivity on Thermo-Mechanical Coupling Behavior in GaN-Based Nanofilm under Pulse Heat Source

Microstructure and Physical Properties of GaN Films on Sapphire Substrates

Local thermal conductivity of polycrystalline AlN ceramics measured by scanning thermal microscopy and complementary scanning electron microscopy techniques

Measurements and numerical calculations of thermal conductivity to evaluate the quality of β-gallium oxide thin films grown on sapphire and silicon carbide by molecular beam epitaxy

Dissimilar Thermal Transport Properties in Κ-Ga2o3 and Β-Ga2o3 Revealed by Homogeneous Nonequilibrium Molecular Dynamics Simulations Using Machine-Learned Potentials

Thermal Transport Characterization of Monolayer GaN Nanoribbon Doped with Group IV Materials: An Equilibrium Molecular Dynamics Study

Ballistic Thermal Transport at Sub-10 nm Laser-Induced Hot Spots in GaN Crystal

High Thermal Boundary Conductance across Bonded Heterogeneous GaN-SiC Interfaces

Thermal Conductance Across Harmonic-matched Epitaxial Al-sapphire Heterointerfaces

An Electron–phonon Monte Carlo Study on Thermal Transport in GaN

Enhanced Thermal Boundary Conductance across GaN/SiC Interfaces with AlN Transition Layers

Thermodynamic Studies of \b{eta}-Ga2O3 Nanomembrane Field-Effect Transistors on a Sapphire Substrate

Anisotropic Thermal Conductivity of the Nanoparticles Embedded GaSb Thin Film Semiconductor.

Interfacial Thermal Conductance across Room-Temperature-Bonded GaN/Diamond Interfaces for GaN-on-Diamond Devices

Characterization of Gan/Sapphire Interface and the Buffer Layer by TEM/AFM

Correlation of heat transport mechanism and structural properties of GaN high electron mobility transistors

Study on 3D Thermal Transport in Micro-Leds on GaN Substrate at the Level of Kw/cm2

Cross-plane thermal conductivity of GaN/AlN superlattices