Abstract:Grain sizes, impurities, and layer thicknesses in the nm-range affect the heat transport and, hence, hinder proper heat dissipation of GaN-based devices. To obtain a clear picture of heat dissipation, the mechanisms of heat transport must be linked to the structural properties of the nitride-based materials in the device. In this paper, a systematic investigation of the typical layers of GaN high-electron mobility transistor stacks was conducted by time-domain thermoreflectance analysis and Raman measurements. The analyzed layers are the AlN nucleation layer, the Al0.3Ga0.7N transition layer, the AlGaN/AlN superlattice, the C-doped GaN back-barrier, and the uid GaN layer. The results were interpreted using the Born–van Karman model, including the suppression function approach to describe the governing heat transport mechanisms. Investigation of this AlN nucleation layer showed that its phonon scattering is dominated by impurity and grain boundary scattering. The Al0.3Ga0.7N transition layer was shown to have a reduced thermal conductivity not only due to alloy scattering but also because of grain boundary scattering. The AlGaN/AlN superlattice showed a thermal conductivity lower than the Al0.3Ga0.7N transition layer, especially at higher temperatures (7.2 ± 0.2 W/mK vs 14.1 ± 0.4 W/mK at 300 °C). Caused by the enhanced AlGaN/AlN interface density, the thermal conductance was found to be 2 GW/m2 K. The AlGaN/AlN superlattice indicated an anisotropic thermal transport with a factor of ∼1.5. The C-doped GaN layers were analyzed in terms of their size-dictated thermal conductivity, resulting in a reduction of ∼66% from 1 μm to 250 nm at 30 °C. Raman spectroscopy revealed that the thicker the GaN layer, the higher the compressive stress in GaN, which additionally results in a higher thermal transport. The investigations of the heat transport depending on the structural properties enabled an accurate determination of the thermal conductivity of the layer stack. These thermal conductivities served as input parameters for 3D simulation to extract the temperature, in terms of the thermal resistance, of such high-electron mobility transistor stacks. This simulation shows the importance of the GaN layer in terms of thermal management. This work uncovers the thermal transport in GaN-based transistor stacks with the aim to improving the thermal design.

Ballistic Thermal Transport at Sub-10 nm Laser-Induced Hot Spots in GaN Crystal

Ballistic Thermal Transport at Sub‐10 Nm Laser‐Induced Hot Spots in GaN Crystal (adv. Sci. 2/2023)

Observation of ballistic-diffusive thermal transport in GaN transistors using thermoreflectance thermal imaging

Ballistic-phonon Heat Conduction at the Nanoscale As Revealed by Time-Resolved X-Ray Diffraction and Time-Domain Thermoreflectance

Thermal Transport of Nanoporous Gallium Nitride for Photonic Applications

Coupled Nonequilibrium Monte Carlo Simulations of Thermal Transport Mediated by Nanoscale Hotspot in GaN Transistors

Ballistic Transport Enhanced Heat Convection at Nanoscale Hotspots

Thermal management of vertical gallium nitride nanowire arrays: Cooling design and tip temperature measurement

Studying the Effect of Temperature and Pressure on GaN Crystals Via the Na-flux Method

Observation of Enhanced Heat Transfer Between a Nanotip and Substrate at Nanoscale Distances Via Direct Temperature Probing with Raman Spectroscopy

High-order Phonon Anharmonicity and Thermal Conductivity in GaN

Quasi-ballistic Thermal Transport from Nanoscale Interfaces Observed Using Ultrafast Coherent Soft X-Ray Beams

Thermal analysis of GaN-based photonic membranes for optoelectronics

Quasiballistic Thermal Transport from Nanoscale Heaters and the Role of the Spatial Frequency

B13-P-01Temperature Characterization of Self-heating in GaN-based Transistors by Cathodeluminescence Spectroscopy

Correlation of heat transport mechanism and structural properties of GaN high electron mobility transistors

Anomalously Temperature-Dependent Thermal Conductivity of Monolayer Gan with Large Deviations from the Traditional 1/T Law

Study on 3D Thermal Transport in Micro-Leds on GaN Substrate at the Level of Kw/cm2

Phonon Transport Across GaN/AlN Interface: Interfacial Phonon Modes and Phonon Local Non-Equilibrium Analysis

Thermal Characterization of GaN Heteroepitaxies Using Ultraviolet Transient Thermoreflectance

Thermal Transport Characterization of Monolayer GaN Nanoribbon Doped with Group IV Materials: An Equilibrium Molecular Dynamics Study