Abstract:In the present study, ZrB2 nanoparticles were synthesized using sol-gel method. Zirconium alkoxide was used as the source of zirconium and boric acid as the source of boron. The size of precursor nanoparticle was controlled using the pH parameter inside the sol, and the formation of primary nuclei of ZrB2 phase and their crystallized amount were investigated using the temperature parameter. To evaluate the mechanism of product formation during the sol-gel process, TEM, SEM, DTA/TG, RAMAN, XRD, FTIR, and DLS methods were used. DLS analysis showed that the size of precursor particle inside the sol at pH less than 5 was below 10 nm. Measurements of viscosity and zeta potential inside the sol showed that in the acidic range, the particle stability decreases with increasing pH. Mixing of precursor particles at molecular level inside the sol was one of the important reasons in reducing the synthesis temperature of ZrB2 particles. FTIR analysis on chemical bonds showed that Zr-O-B bond was formed inside the gel powder. DTA analysis showed that the primary nuclei of ZrB2 particles were formed at a temperature of about 1400 °C. XRD observations proved that the primary nuclei of the ZrB2 phase crystallized and grew at a temperature of about 1500 °C. Surface research revealed that the specific surface area of the synthesized ZrB2 particles is equivalent to 115 m2/g, and also the surfaces of these particles are porous, and the size of these porosities is in meso range. SEM analysis showed that the particle size of ZrB2 having homogeneous morphology is about 50 nm. TEM microstructural analysis revealed that ZrB2 particles were formed uniformly and orderly in very fine dimensions.Graphical abstract

A Novel Non-Aqueous Solvent Chemical Process To Synthesize Nano-Zro2

Synthesis, Characterization and Application of Submicron ZrSiO4 Powder Via Sol-Gel-microemulsion-hydrothermal Method

Preparation of Zirconia Powders by Sol-gel Process

Hydrothermal Synthesis and Characterization of Zirconia Nanocrystallites

Preparation of High-Surface-Area Sno2 and Zro2 by Reflux-Digestion and Solvothermal Methods

Characterization and Synthesis of Pure Zro2 Nanopowders Via Sonochemical Method

A Simple and Novel Low-Temperature Hydrothermal Synthesis of ZnO Nanorods

Preparation of ZrO2 Nano-Particles by the Hydrolysis of ZrOCl2 Solution in the Reverse Micelles

Facile Synthesis and Characterization of ZrO₂ Nanoparticles via Modified Co-Precipitation Method

Preparation of Nano-ZrO2 powder via a microwave-assisted hydrothermal method

Preparation of Zro2 Micro Beads by Sol-Gel Method

Preparation of amorphous ZrO2 powders by hydrothermal-assisted sol-gel method

Nanocrystalline Rare Earth Stabilized Zirconia: Solvothermal Synthesis Via Heterogeneous Nucleation-Growth Mechanism, and Electrical Properties

Ethanol-induced formation of precursor for 8mol% Yttria-stabilized zirconia: Towards the production of well-dispersed, easily sintering, and high-conductivity nano-powders

Preparation of Zirconia Base Solid Solution Nanopowder by Exothermal Solid-State Synthesis

Phase Composition Controllable Preparation of Zirconia Nanocrystals Via Solvothermal Method

Improvement of ZrB2 nanopowder synthesis by sol-gel method via zirconium alkoxide/boric acid precursors

Study on a new, environmentally benign method and its feasibility of preparing nanometer zirconia powder

Study on the process and properties of nano-sized polycrystal zirconia powders by co-precipitation in super-alkaline medium

From modification to mechanism: Supercritical hydrothermal synthesis of nano-zirconia

Monoclinic zirconium oxide nanostructures synthesized by a hydrothermal route